煤粉的增压富氧燃烧特性及煤灰矿物演变

王春波; 雷鸣; 阎维平; 王松岭

煤粉的增压富氧燃烧特性及煤灰矿物演变

华北电力大学能源动力与机械工程学院, 河北保定 071003

基金项目: 国家高技术研究发展计划(863计划, 2009AA05Z310); 教育部新世纪优秀人材支持计划(NCET-08-0770)。

详细信息

通讯作者:
王春波(1973-), 男, 河北唐山人, 教授. 研究方向为煤的洁净燃烧. E-mail: hdwchb@126.com.

中图分类号: TK16
计量
- 文章访问数: 2288
- HTML全文浏览量: 14
- PDF下载量: 881
- 被引次数: 0
出版历程
- 收稿日期: 2011-10-23
- 修回日期: 2011-12-09
- 刊出日期: 2012-07-31

Combustion characteristics of pulverized coal and mineral conversion under pressurized oxy-fuel condition

School of Energy Power and Mechanical Engineering, North China Electric Power University, Baoding 071003, China

摘要

摘要: 为了更好地了解煤粉在增压富氧条件下的燃烧过程,利用加压热天平(PTGA)结合X射线衍射仪(XRD),研究了增压富氧燃烧条件下压力对煤粉燃烧特性及煤中矿物演变的影响。研究表明,随着压力的升高,煤粉常压时的非均相着火逐渐转变为均相着火,当压力升高到3 MPa开始向非均相着火过渡,并在5 MPa时完全转变成非均相着火。由于煤粉着火机理的转变,综合燃烧特性指数S随着压力的增加先升高后降低。不同的着火机理下,煤粉的燃烧温度也会有所差别。常压时非均相着火较高的燃烧温度使得反应生成了莫来石等矿物,而1 MPa时均相着火较低的燃烧温度则使得煤灰中出现了伊利石等矿物。压力继续升高,均相着火开始向非均相着火过渡,燃烧温度逐步升高,伊利石逐渐转变为莫来石。
- 增压富氧燃烧 /
- 燃烧特性 /
- 煤灰 /
- 矿物演变 /
- 压力
Abstract: To better understand the combustion process of pulverized coal under pressurized oxy-fuel atmosphere, the influence of pressure on the combustion characteristics and mineral conversion during the pressurized oxy-fuel combustion was investigated by using the combination of pressurized thermogravimetric analyzer (PTGA) and X-ray diffractometer (XRD). The results indicate that the heterogeneous ignition at atmospheric pressure changes to the homogeneous ignition with the increase of pressure, but starts to change to the heterogeneous ignition gradually at 3 MPa, and becomes the heterogeneous ignition at 5 MPa. As a result of the transformation of ignition mechanism of pulverized coal, the combustibility index S increases firstly and then reduces with pressure. And the combustion temperatures may be different for different ignition mechanisms. Because of higher combustion temperature of the heterogeneous ignition at atmospheric pressure, some minerals, such as mullite, are generated in the ash, while some other minerals, such as illite, are found in the ash owing to lower combustion temperature of the homogeneous ignition at 1 MPa. As the pressure continues rising, the illite converts to mullite due to the homogeneous ignition transforming to the heterogeneous ignition.
- pressurized oxy-fuel combustion /
- combustion characteristics /
- coal ash /
- mineral conversion /
- pressure

HTML全文

参考文献(14)

MYOHANEN K, HYPPANEN T, PIKKARAINEN T, ERIKSSON T, HOTTA A. Near zero CO₂ emissions in coal firing with oxy-fuel circulating fluidized bed boiler[J]. Chem Eng Technol, 2009, 32(3): 355-363.

FASSBENDER A. Pressurized oxy-fuel combustion for multi-pollutant capture//The 30th International Technical Conference on Coal Utilization and Fuel Systems. Clearwater, FL, USA: Coal Technologies Associates,2005.

HENRY R. Modeling of pressurized oxy-fuel for recovery of latent heat and carbon capture using usibelli coal//The 32nd International Technical Conference on Coal Utilization and Fuel Systems. Clearwater, FL, USA:Coal Technologies Associates, 2007.

ZHENG C, ZHENG L, POMALIS R, TURNER R, CLEMENTS B. Conceptual design and experimental study overview: Flue gas treatment and CO₂ recovery experimental system for high pressure oxygen fired coal combustion//The 33rd International Technical Conference on Coal Utilization and Fuel Systems. Clearwater, FL, USA: Coal Technologies Associates,2008.

HONG J. Techno-economic analysis of pressurized oxy-fuel combustion power cycle for CO₂ capture. Cambridge: MIT, 2007.

HUANG X, JIANG X, HAN X, WANG H. Combustion characteristics of fine-and micro-pulverized coal in the mixture of O₂/CO₂[J]. Energy Fuels, 2008, 22(6): 3756-3762.

SAASTAMOINEN J J, AHO M J, HAMALAINEN J P, HERNBERG R, JOUTSENOJA T. Pressurized pulverized fuel combustion in different concentrations of oxygen and carbon dioxide[J]. Energy Fuels, 1996, 10(1): 121-133.

SUN C L, ZHANG M Y. Ignition of coal particles at high pressure in a thermogravimetric analyzer[J]. Combust Flame, 1998, 115(1/2): 267-274.

LI Q, ZHAO C, CHEN X, WU W, LI Y. Comparison of pulverized coal combustion in air and in O₂/CO₂ mixtures by thermo-gravimetric analysis[J]. J Anal Appl Pyrolysis, 2009, 85(1/2): 521-528.

GADIOU R, BOUZIDI Y, PRADO G. The devolatilisation of millimetre sized coal particles at high heating rate:The influence of pressure on the structure and reactivity of the char[J]. Fuel, 2002, 81(16): 2121-2130.

YANG H, CHEN H, JU F, YAN R, ZHANG S. Influence of pressure on coal pyrolysis and char gasification[J]. Energy Fuels, 2007, 21(6):3165-3170.

姜秀民,李巨斌,邱健荣.超细化煤粉燃烧特性的研究[J].中国电机工程学报,2000,20(6):71-78. (JIANG Xiu-min, LI Ju-bin, QIU Jian-rong. Study on combustion characteristic of micro-pulverized coal[J]. Proceedings of CSEE, 2000, 20(6): 71-78.)

HUDA M, KORAI Y, MOCHIDA I. Reactivities of blair athol and nang tong coals in relation to their behavior in PFBC boiler[J]. Fuel, 2004, 83(16): 2151-2156.

SHENG C, LI Y. Experimental study of ash formation during pulverized coal combustion in O₂/CO₂ mixtures[J]. Fuel, 2008, 87(7): 1297-1305.

施引文献

资源附件(0)

访问统计