Steam re-gasification properties and kinetics of coal char fines derived from fluidized bed gasifier
-
摘要: 利用热天平考察了流化床气化炉半焦细粉的水蒸气再气化特性及其动力学,并与相应的自制半焦及脱灰半焦细粉进行了比较分析.结果表明,半焦细粉的再气化反应性随着温度的升高而增加.与自制热解半焦相比,半焦细粉的反应性较高,这主要取决于比表面积的影响,而不同细粉的气化反应性差异还与其石墨化程度和灰含量有关.在此基础上,利用缩核模型对半焦细粉的再气化行为进行了模型拟合并得到了动力学参数,从而为细粉的再气化提供了一定的理论指导.Abstract: The steam gasification behavior and kinetics of coal char fines derived from fluidized bed gasifier were investigated by TGS-2 thermogravimetric analyzer. Their physical and chemical properties were also compared with the corresponding coal chars and demineralized char fines. The results show that the gasification reactivity of char fines increase with increasing temperature. Compared with the coal char from pyrolysis, the char fine has a larger surface area and leads to a higher gasification reactivity. The reactivity of different coal char fines are also affected by their carbon crystalline structure and ash content. Based on this, the gasification reactions are described by the shrinking core model and the kinetic parameters are obtained, so as to provide some theoretical guides for the gasification of coal char fines.
-
Key words:
- coal char fines /
- steam gasification /
- pore structure /
- gasification kinetics
-
屈利娟. 流化床煤气化技术的研究进展[J]. 煤炭转化, 2007, 30(2): 81-85. (QU Li-juan. Process of research in the fluidized bed coal gasification technology[J]. Coal Conversion, 2007, 30(2): 81-85.) 许世森, 张东亮, 任永强. 大规模煤气化技术[M]. 北京: 化学工业出版社, 2006. (XU Shi-seng, ZHANG Dong-liang, REN Yong-qiang. Large-scale coal gasification technology[M]. Beijing: Chemical Industry Press, 2006.) KELEBOPILE L, SUN R, LIAO J. Fly ash and coal char reactivity from thermo-gravimetric (TGA) experiments[J]. Fuel Process Technol, 2011, 92(6): 1178-1186. GU J, WU S, WU Y, LI Y, GAO J . Differences in gasification behaviors and related properties between entrained gasifier fly ash and coal char[J]. Energy Fuels, 2008, 22(6): 4029-4033. 房倚天, 吴晋沪, 张建民, 王洋. 流化床气化炉飞灰气化反应性的研究:Ⅱ飞灰气化动力学的研究[J]. 燃料化学学报, 1996, 24(3): 225-232. (FANG Yi-tian, WU Jin-hu, ZHANG Jian-min, WANG Yang. Study on gasification reactivity of fly ash from a fluidized bed gasifier :Ⅱ study on gasification reaction kinetics of fly ash[J]. Journal of Fuel Chemistry and Technology, 1996, 24(3): 225-232.) 刘武标, 刘德昌, 米铁, 陈汉平, 张世红. 流化床水煤气炉飞灰反应性的实验研究[J]. 中国电机工程学报, 2003, 23(9): 189-192. (LIU Wu-biao, LIU De-chang, MI Tie, CHEN Han-pin, ZHANG Shi-hong. Experimental research on reactivity of fly ash from a fluidized bed water-gas gasifier[J]. Proceedings of the CSEE, 2003, 23(9): 189-192.) ZHANG L, HUANG J, FANG Y, WANG Y. Gasification reactivity and kinetics of typical Chinese anthracite chars with stream and CO2[J]. Energy Fuels, 2006, 20(3): 1201-1210. TAKARADA T, TAMAI Y, TOMITA A. Reactivities of 34 coals under stream gasification[J]. Fuel, 1985, 64(10): 1438-1442. 乌晓江, 张忠孝, 朴桂林, 小林信介, 森滋勝, 板谷義紀. 高灰熔点煤高温下煤焦CO2/水蒸气气化反应特性的实验研究[J]. 中国电机工程学报, 2007, 27(32): 24-27. (WU Xiao-jiang, ZHANG Zhong-xiao, PIAO Gui-lin, KOBAYASHI N, MORI S, ITATYA Y. Experimental study on gasification reaction characteristics of Chinese high ash fusion temperature coal with CO2 and steam at elevated temperature[J]. Proceeding of the CSEE, 2007, 27(32): 24-27.) 任海军, 张永奇, 房倚天, 黄戒介, 王洋. 褐煤焦中的矿物质对气化动力学的影响[J]. 化学工程, 2010, 38(10): 132-135. (REN Hai-jun, ZHANG Yong-qi, FANG Yi-tian, HUANG Jie-jie, WANG-Yang. Effect of minerals in lignite char on kinetics of stream gasification [J]. Chemical Engineering (China), 2010, 38(10): 132-135) OCHOA J, CASSANELLO M C, BONELLI P R, CUKIERMAN A L. CO2 gasification of Argentinean coal chars: A kinetic characterization[J]. Fuel Process Technol, 2001, 74(3): 161-176. 许慎奇, 周志杰, 杨帆, 于广锁, 于遵宏. 快速热解温度下的淮南煤焦与水蒸气气化反应的研究[J]. 高校化学工程学报, 2008, 22(6): 947-953. (XU Shen-qi, ZHOU Zhi-jie, YANG Fan, YU Guang-suo, YU Zun-hong. Effects of pyrolysis temperature on stream gasification of Huainan char[J]. Journal of Chemical Engineering of Chinese Universities, 2008, 22(6): 947-953.) 李庆峰, 房倚天, 张建民, 王洋, 时铭显, 孙国刚. 气化活性与孔比表面积的关系[J]. 煤炭转化, 2003, 26(3): 45-48. (LI Qing-feng, FANG Yi-tian, ZHANG Jian-min, WANG Yang, SHI Ming-xian, SUN Guo-gang. Relationship of gasification activity and pore structure[J]. Coal Conversion, 2003, 26(3): 45-48.) ZHUO Y, MESSENBÖCK R, COLLOT A G, MEGARITIS A, PATERSON N, DUGWELL D R, KANDIYOTI R. Conversion of coal particles in pyrolysis and gasification: Comparison of conversions in a pilot-scale gasifier and bench-scale test equipment[J]. Fuel, 2000, 79(7): 793-802.
点击查看大图
计量
- 文章访问数: 1543
- HTML全文浏览量: 20
- PDF下载量: 689
- 被引次数: 0