粉体对分解炉内SNCR反应影响的研究

付世龙; 宋蔷; 仲蕾; 姚强

粉体对分解炉内SNCR反应影响的研究

清华大学热科学与动力工程教育部重点实验室, 北京 100084

基金项目: 国家科技支撑计划(2011BAE29B03)。

详细信息

通讯作者:
宋蔷, 副研究员, E-mail: qsong@mail.tsinghua.edu.cn。

中图分类号: TK16
计量
- 文章访问数: 1549
- HTML全文浏览量: 23
- PDF下载量: 665
- 被引次数: 0
出版历程
- 收稿日期: 2012-10-13
- 修回日期: 2012-12-29
- 刊出日期: 2013-05-30

Influence of calcium-based particles on the selective non-catalytic reduction process in a pre-calciner

Key Laboratory of Thermal Science and Power Engineering of Ministry of Education, Tsinghua University, Beijing 100084, China

摘要

摘要: 采用滴管炉反应器,针对钙基粉体对分解炉环境下SNCR反应的影响进行了研究。考察了NH₃和尿素两种还原剂对不同温度(600~1 100 ℃)、氨氮比(0.5~2.0)和氧浓度(0.5%~5.0%)下SNCR反应的影响。实验结果表明,生料、CaO和CaCO₃三种粉体都对分解炉条件下两种还原剂的SNCR反应均有抑制作用,低温下粉体的抑制作用较为明显,高温下粉体的抑制逐渐减弱。低温下生料的抑制作用强于CaCO₃和CaO,主要是生料中活性杂质的催化作用;高温下CaO的抑制作用最强,之后是CaCO₃和生料。随着氨氮比的增加,SNCR脱硝效率增强,粉体对脱硝效率的抑制程度基本不变。生料的最佳脱硝氧浓度为1%,而CaCO₃和CaO的最佳脱硝氧浓度为2%。有粉体存在下的SNCR反应特性是气相脱硝反应与还原剂气固催化氧化反应竞争的结果。
- SNCR /
- 脱硝 /
- NO /
- 分解炉
Abstract: The influence of calcium-based particles on the selective non-catalytic reduction (SNCR) process was investigated in a drop tube furnace reactor; the tests under different temperatures (600~1 100 ℃), normalized stoichiometric ratio (NSR) of NH₃/NO (0.5~2.0) and O₂ concentrations (0.5%~5.0%), with ammonia and urea as reducing agents, were considered. The results showed that the raw material, CaCO₃ and CaO have inhibitive effect on the SNCR performance; the extent of this effect is significant at low temperature but attenuates with the increase of temperature. Raw material exhibits the strongest inhibitive effect on the SNCR at low temperature because of the catalytic activity of impurity in the raw materials, while CaO has the strongest effect at high temperature. The efficiency of SNCR is increased by increasing NSR, while the effect of calcium-based particles on SNCR remains unchanged. The optimal O₂ concentrations for NO_x removal is 1% with raw material and 2% with CaCO₃ and CaO. The SNCR performance in the presence of calcium-based particles is characterized by the competition of denitration reactions between gaseous de-NO_x and the particle-catalyzed oxidation of reductant.
- SNCR /
- De-NO_x /
- NO /
- pre-calciner

HTML全文

参考文献(15)

胡芝娟. 分解炉氮氧化物转化机理及控制技术研究[D]. 武汉: 华中科技大学, 2004. (HU Zhi-juan. The study on mechanism of nitrogen oxides transformation and control technology for pre-calciner[D]. Wuhan: Huazhong University of Science and Technology, 2004.)

Alternative control techniques document update-NO_x emissions from new cement kilns[R]. USA: North Carolina: Environmental Protection Agency, 2007.

MCQUEEN A, BORTZ S, HATCH M, LEONARD R. Cement kiln NO_x control[J]. IEEE Trans Ind Appl, 1995, 31(1): 36-44.

STEUCH H, HILLE J, SUN W, BISNETT M. Reduction of NO_x emissions from a dry process preheater kiln with calciner through the use of the urea-based SNCR process[J]. IEEE Trans Ind Appl, 1996, 32(4): 753-759.

BAUER C. Pyro-jet burners to reduce NO_x emissions-current developments and practical experience[J]. World Cement, 1990, 21(4): 118-124.

李天津, 禚玉群, 陈昌和, 徐旭常. 700~850℃内H₂O对CaO上NH₃氧化的影响[J]. 工程热物理学报, 2009, 30(7): 1233-1236. (LI Tian-jin, ZHUO Yu-qun, CHEN Chang-he, XU Xu-chang. Effect of water vapor on NH₃ oxidation over CaO at 700~850℃[J]. Journal of Engineering Thermophysics, 2009, 30(7): 1233-1236.)

唐君实. 预分解窑内钙基颗粒对SNCR脱硝过程影响的研究[D]. 北京: 清华大学, 2011. (TANG Jun-shi. Study on the influence of Ca-based particles on SNCR in pre-calciner[D]. Beijing: Tsinghua University, 2011.)

唐君实, 宋蔷, 高攀, 姚强. SNCR应用于水泥窑氮氧化物控制的氨氧化[J]. 清华大学学报, 2011, 51(6): 831-835. (TANG Jun-shi, SONG Qiang, GAO Pan, YAO Qiang. NH₃ oxidation using SNCR to control cement kiln NO_x[J]. Journal of Tsinghua University Science and Technology, 2011, 51(6): 831-835.)

ZIJLMA G, JENSEN A, JOHNSSON J, van den BLEEK C. NH₃ oxidation catalyzed by calcined limestone—a kinetic study[J]. Fuel, 2002, 81(14): 1871-1881.

ZIJLMA G, JENSEN A, JOHNSSON J, van den BLEEK C. NH₃ oxidation catalyzed by partially sulfated limestone—modeling and experimental work[J]. Fuel, 2004, 83(2): 237-251.

ZIJLMA G, JENSEN A, JOHNSSON J, van den BLEEK C. Influence of H₂O and CO₂ on the reactivity of limestone for the oxidation of NH₃[J]. Fuel, 2000, 79(12): 1449-1454.

李天津. 中温钙基脱硫条件下喷NH₃脱除NO的实验研究[D]. 北京: 清华大学, 2004. (LI Tian-jin. Experimental study on NO reduction by NH₃ in desulfurization with Ca-based sorbent at moderate temperatures[D]. Beijing: Tsinghua University, 2004.)

唐君实, 宋蔷, 吴兴远, 付世龙, 姚强. CaCO₃对NH₃氧化的影响[J]. 中国电机工程学报, 2011, 31(35): 35-40. (TANG Jun-shi, SONG Qiang, WU Xing-yuan, FU Shi-long, YAN Qiang. Influence of CaCO₃ on NH₃ oxidation[J]. Proceedings of the CSEE, 2011, 31(35): 35-40.)

唐君实, 宋蔷, 吴兴远, 付世龙, 高攀. CaCO₃对NH₃+NO+O₂反应体系的影响[J]. 东北师大学报, 2011, 43(3): 101-105. (TANG Jun-shi, SONG Qiang, WU Xing-yuan, FU Shi-long, GAO Pan. Experimental study of the influence of CaCO₃ on NH₃+NO+O₂ reaction system[J]. Journal of Northeast Normal University, 2011, 43(3): 101-105.)

SHMIZU T, KARAHASHI E, YAMAGUCHI T, INAGAKI M. Decomposition of NH₃ over calcined and uncalciner limestone under fluidized-bed combustion conditions[J]. Energy Fuels, 1995, 9(6): 962-965.

施引文献

资源附件(0)

访问统计