300 MW燃煤电站砷、汞排放特征研究

张凯华; 张锴; 潘伟平

300 MW燃煤电站砷、汞排放特征研究

1.
华北电力大学能源动力与机械工程学院热电生产过程污染物监测与控制北京市重点实验室, 北京 102206;
2.
Institute for Combustion Science and Environmental Technology, Western Kentucky University, Bowling Green, Kentucky 42101, USA

基金项目: 中央高校基本科研业务费专项资金(13QN11).

详细信息

通讯作者:
张凯华

中图分类号: X773
计量
- 文章访问数: 1466
- HTML全文浏览量: 20
- PDF下载量: 662
- 被引次数: 0
出版历程
- 收稿日期: 2013-06-01
- 修回日期: 2013-06-24
- 刊出日期: 2013-07-30

Emission characteristics of arsenic and mercury from a 300 MW coal-fired power plant

1.
Beijing Key Laboratory of Emission Surveillance and Control for Thermal Power Generation, Department of Energy Power & Mechanical Engineering, North China Electric Power University, Beijing 102206, China;
2.
Institute for Combustion Science and Environmental Technology, Western Kentucky University, Bowling Green, Kentucky 42101, USA

摘要

摘要: 对某300 MW燃煤电站煤、底灰和静电除尘器(ESP)飞灰进行采样并测定了其中的砷、汞含量,同时应用Ontario Hydro Method (OHM) 标准方法和设备对ESP前后烟气中的砷、汞分布进行了直接采样和测试.对砷的检测结果表明,ESP飞灰中砷含量约6.68×10^-6,是原煤中砷含量的2.5倍左右,而底灰中砷含量仅为1.70×10^-6,ESP前烟气中砷含量约153.27 μg/m³,ESP后砷含量急剧降低为41.13 μg/m³;对汞的检测结果表明,原煤中汞含量约2.5×10^-7,飞灰、底灰中的汞含量分别约1.9×10^-7、1.5×10^-7;ESP前后烟气中总汞含量分别为5.49、5.21 μg/m³.砷在飞灰中明显富集,而汞在飞灰和底渣中均不具有富集效果.ESP单元具有明显的协同脱砷效果,平均脱除率约在71%左右,而对汞的协同脱除效果不明显.
- 砷 /
- 汞 /
- 排放 /
- 烟气 /
- 飞灰
Abstract: An emissions studies for arsenic and mercury were conducted at a 300 MW coal-fired power plant. The solid streams such as coal, bottom ash and ESP ash were collected, and the arsenic and mercury in the flue gas around ESP were aslo directly sampled using Ontario Hydro Method and then tested. The results show that the arsenic concentration in fly ash is about 6.68×10^-6, which is almost 2.5 times as that in coal, nevertheless that in bottom ash is only 1.70 ×10^-6. Its concentration in the flue gas is 153.27 and 41.13 μg/m³ before and after ESP, respectively. The mercury concentration in coal, fly ash and bottom ash is about 2.5×10^-7, 1.9×10^-7 and 1.5×10^-7 respectively, its concentration in the flue gas before and after ESP was about 5.49 and 5.21 μg/m³. Arsenic is significantly concentrated in fly ash, whereas mercury is not. ESP unit has obvious synergistic effect on arsenic removal up to 71%, while it is not obvious for mercury removal.
- arsenic /
- mercury /
- emission /
- flue gas /
- fly ash

HTML全文

参考文献(29)

张军营, 任德贻, 许德伟, 赵峰华. 煤中汞及其对环境的影响[J]. 环境科学进展, 1999, 7(3): 100-104. (ZHANG Jun-ying, REN De-yi, XU De-wei, ZHAO Feng-hua. Mercury in coal and its effect on environment[J]. Advances in Environmental Science, 1999, 7(3): 100-104.)

NG J C, WANG J P, SHRAIM A. A global health problem caused by arsenic from natural sources[J]. Chemosphere, 2003, 52(9): 1353-1359.

蒋靖坤, 郝吉明, 吴烨, STREETS D G, 段雷, 田贺忠. 中国燃煤汞排放清单的初步建立[J]. 环境科学, 2005, 26(2): 34-39. (JIANG Jing-kun, HAO Ji-ming, WU Ye, STREETS D G, DUAN Lei, TIAN He-zhong. Development of mercury emission inventory from coal combustion in China[J]. Environmental Science, 2005, 26(2): 34-39. )

郭欣, 郑楚光, 陈丹. 300MW煤粉锅炉砷排放特征的实验研究[J]. 环境科学, 2006, 27(4): 631-634. (GUO Xin, ZHENG Chu-guang, CHEN Dan. Characterization of arsenic emissions from a coal-fired power plant[J]. Environmental Science, 2006, 27(4): 631-634.)

胡长兴, 周劲松, 何胜, 骆仲泱, 岑可法. 我国典型电站燃煤锅炉汞排放量估算[J]. 热力发电, 2010, 39(3): 1-4. (HU Chang-xing, ZHOU Jin-song, HE Sheng, LUO Zhong-yang, CEN Ke-fa. Estimation of mercury emission from coal-fired boilers in typical power plants of China[J]. Thermal Power Generation, 2010, 39(3): 1-4.)

王起超, 沈文国, 麻壮伟. 中国燃煤汞排放量估算[J]. 中国环境科学, 1999, 19(4): 318-321. (WANG Qi-chao, SHEN Wen-guo, MA Zhuang-wei. The estimation of mercury emission from coal combustion in China[J]. China Environmental Science, 1999, 19(4): 318-321.)

TIAN H Z, WANG Y, XUE Z G, QU Y P, CHAI F H, HAO J M. Atmospheric emissions estimation of Hg, As, and Se from coal-fired power plants in China, 2007[J]. Sci Total Environ, 2011, 409: 3078-3081.

田贺忠, 曲益萍. 2005年中国燃煤大气砷排放清单[J]. 环境科学, 2009, 30(4): 956-962. (TIAN He-zhong, QU Yi-ping. Inventories of atmospheric arsenic emissions from coal combustion in China, 2005[J]. Environmental Science, 2009, 30(4): 956-962.)

王明仕, 郑宝山, FINKELMAN R B, 胡军, 吴代赦, 李社红. 煤中砷赋存状态与其脱洗率的关系[J]. 燃料化学学报, 2005, 33(2): 253-256. (WANG Ming-shi, ZHENG Bao-shan, FINKELMAN R B, HU Jun, WU Dai-she, LI She-hong. Relationship between occurrence mode of arsenic in coal and its washing rate[J]. Journal of Fuel Chemistry and Technology, 2005, 33(2): 253-256.)

陈萍, 旷红伟, 唐修义. 煤中砷的分布和赋存规律研究[J]. 煤炭学报, 2002, 27(3): 259-263. (CHEN Ping, KUANG Hong-wei, TANG Xiu-yi. Research on the distribution and occurrence of arsenic in coal[J]. Journal of China Coal Society, 2002, 27(3): 259-263. )

郑刘根, 刘桂建, CHOU Chen-lin, 高连芬, 彭子成. 中国煤中砷的含量分布、赋存状态、富集及环境意义[J], 地球学报, 2006, 27(4): 355-366. (ZHENG Liu-gen, LIU Gui-jian, Chou Chen-lin, GAO Lian-fen, PENG Zi-cheng. Arsenic in Chinese coals: Its abundance, distribution, modes of occurrence,enrichment processes, and environmental significance[J]. Acta Geoscientica Sinica, 2006, 27(4): 355-366.)

ZIELINSKI R A, FOSTER A L, MEEKER G P. Mode of occurrence of arsenic in feed coal and its derivative fly ash, Black Warrior Basin, Alabama[J]. Fuel, 2007, 86: 560-572.

HUGGINS F E, SENIOR C L, CHU P. Selenium and arsenic speciation in fly ash from full-scale coal-burning utility plants[J]. Environ Sci Technol, 2007, 41(9): 3284-3289.

郭瑞霞, 杨建丽, 刘东艳, 刘振宇. 热处理条件对大同煤中微量有害元素变迁规律的影响[J]. 化工学报, 2003, 54(11): 1603-1607. (GUO Rui-xia, YANG Jian-li, LIU Dong-yan, LIU Zhen-yu. Influence of thermal treatment conditions on transformation of trace elements in Datong coal[J]. Journal of Chemical Industry and Engineering (China), 2003, 54(11): 1603-1607.)

李扬, 张军营, 赵永椿, 吴幼青, 高晋生, 郑楚光. 热解条件对煤中微量元素挥发性影响的实验研究[J]. 工程热物理学报, 2007, 28(2): 189-192. (LI Yang, ZHANG Jun-ying, ZHAO Yong-chun, WU You-qing, GAO Jin-sheng, ZHENG Chu-guang. Influence of pyrolysis conditions on volatility of trace elements in coals[J]. Journal of Eengineering Thermophysics, 2007, 28(2): 189-192.)

王运军, 段钰峰, 杨立国, 孟素丽, 黄治军, 吴成军, 王乾. 湿法烟气脱硫装置和静电除尘器联合脱除烟气中汞的试验研究[J]. 中国电机工程学报, 2008, 28(29): 64-69. (WANG Yun-jun, DUAN Yu-feng, YANG Li-guo, MENG Su-li, HUANG Zhi-jun, WU Cheng-jun, WANG Qian. Experimental study on mercury removal by combined wet flue gas desulphurization with electrostatic precipitator[J]. Proceedings of the CSEE, 2008, 28(29): 64-69.)

张凯华, 孙喆, 曹晏, 潘伟平, 张锴. 能源高效清洁利用及新能源技术, 2012动力工程青年学术论坛论文集. 杭州: 浙江大学出版社, 2012: 77-82. (ZHANG Kai-hua, SUN Zhe, CAO Yan, PAN Wei-ping, ZHANG Kai. Clean and efficient utilization of energy and new energy technology, 2012 youth academic forum for power engineering. Hangzhou: Zhejiang University press, 2012: 77-82.)

THOMPSON D, ARGENT B B. Prediction of the distribution of trace elements between the product streams of the Prenflo gasifier and comparison with reported data[J]. Fuel, 2002, 81(5): 555-570.

ARGENT B B. Thermodynamic equilibrium study of trace element mobilization under air blown gasification conditions[J]. Fuel, 2002, 81(1): 75-89.

ASTM D 6784-02, Standard test method for elemental, oxidized, particle-bound and total mercury in flue gas generated from coal-fired stationary sources (Ontario Hydro Method)[S]. 2008.

CLARKE L, SLOSS L. Trace elements-emissions from coal combustion and gasification[M]. London: IEA Coal Research, 1992.

LOPEZ-ANTON M A, DIAZ-SOMOANO M, SPEARS D A. Arsenic and selenium capture by fly ashes at low temperature[J]. Environ Sci Technol, 2006, 40(12): 3947-3951.

TANAPOM S, JAMES C H. Arsenic and mercury partitioning in fly ash at a kentucky power plant[J]. Energy Fuels, 2003, 17: 1028-1033.

CONSTANCE L S, HELBLE J J. Emissions of mercury, trace elements, and fine particles from stationary combustion source[J]. Fuel Process Technol, 2000, 65-66: 263-288.

ZOLLER W H, GLADNEY E S, DUCE R A. Atmospheric concentrations and sources of trace metals at the South Pole[J]. Science, 1974, 183(4121): 198-200.

雒昆利, 张新民, 陈昌和, 陆毅伦. 我国燃煤电厂砷的大气排放量初步估算[J]. 科学通报, 2004, 49(19): 2014-2019. (LUO Kun-li, ZHANG Xin-min, CHEN Chang-he, LU Yi-lun. Estimation of arsenic emission from coal-fired power plants of China[J]. Chinese Science Bulletin, 2004, 49(19): 2014-2019. )

TANG Q, LIU G J, YAN Z C, SUN R Y. Distribution and fate of environmentally sensitive elements (arsenic, mercury, stibium and selenium) in coal-fired power plants at Huainan, Anhui, China[J]. Fuel, 2012, 95: 334-339.

王运军, 段钰锋, 杨立国, 江贻满, 吴成军, 王乾, 杨详花. 燃煤电站布袋除尘器和静电除尘器脱汞性能比较[J]. 燃料化学学报, 2008, 36(1): 23-29. (WANG Yun-jun, DUAN Yu-feng, YANG Li-guo, JIANG Yi-man, WU Cheng-jun, WANG Qian, YANG Xiang-hua. Comparison of mercury removal characteristic between fabric filter and electrostatic precipitators of coal-fired power plants[J]. Journal of Fuel Chemistry and Technology, 2008, 36(1): 23-29. )

钟丽萍, 曹晏, 李文英, 潘伟平, 谢克昌. 燃煤电厂污染控制单元对汞释放的控制作用[J]. 燃料化学学报, 2010, 38(6): 641-646. (ZHONG Li-ping, CAO Yan, LI Wen-ying, PAN Wei-ping, XIE Ke-chang. Effect of the existing air pollutant control devices on mercury emission in coal-fired power plants[J]. Journal of Fuel Chemistry and Technology, 2010, 38(6): 641-646. )

施引文献

资源附件(0)

访问统计