留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

木醋调质石灰石用于O2/CO2燃煤同时脱硫脱硝性能

韩奎华,  齐建荟,  李辉,  刘洪涛,  路春美

downloadPDF
文章导航 > 燃料化学学报（中英文）  > 2013 >  41(11): 1378-1383
韩奎华, 齐建荟, 李辉, 刘洪涛, 路春美. 木醋调质石灰石用于O2/CO2燃煤同时脱硫脱硝性能[J]. 燃料化学学报（中英文）, 2013, 41(11): 1378-1383.
引用本文: 韩奎华, 齐建荟, 李辉, 刘洪涛, 路春美. 木醋调质石灰石用于O2/CO2燃煤同时脱硫脱硝性能[J]. 燃料化学学报（中英文）, 2013, 41(11): 1378-1383.
shu
HAN Kui-hua, QI Jian-hui, LI Hui, LIU Hong-tao, LU Chun-mei. Performance of simultaneous desulfurization and denitration using limestone modified by wood vinegar in O2/CO2 coal combustion[J]. Journal of Fuel Chemistry and Technology, 2013, 41(11): 1378-1383.
Citation: HAN Kui-hua, QI Jian-hui, LI Hui, LIU Hong-tao, LU Chun-mei. Performance of simultaneous desulfurization and denitration using limestone modified by wood vinegar in O2/CO2 coal combustion[J]. Journal of Fuel Chemistry and Technology, 2013, 41(11): 1378-1383.
shu

木醋调质石灰石用于O2/CO2燃煤同时脱硫脱硝性能

  • 山东大学 能源与动力工程学院, 山东 济南 250061

基金项目: 国家自然科学基金(51206096)。
详细信息
    通讯作者:

    韩奎华(1978- ),男,山东青州人,副教授。Tel:0531-88392414;E-mail:hankh@163.com。

  • 中图分类号: TQ534.9

Performance of simultaneous desulfurization and denitration using limestone modified by wood vinegar in O2/CO2 coal combustion

  • School of Energy and Power Engineering, Shandong University, Jinan 250061, China

    摘要
  • 摘要: 采用管式炉和沉降炉分别研究了O2/CO2气氛下燃煤预混和烟气喷入木醋调质石灰石的同时脱硫脱硝性能。结果表明,在温度1 173~1 323 K、钙硫比为2.0的条件下,木醋调质石灰石混煤燃烧脱硫效率91.0%~94.9%、脱硝效率23.5%~30.8%。随着钙硫比的增加,木醋调质石灰石混煤燃烧脱硫脱硝效率增大,适宜的钙硫比为1.5~2.0。相同的燃烧温度和钙硫比,含硫量高的煤预混木醋调质石灰石燃烧获得较高的脱硫、脱硝效率。木醋调质石灰石用于O2/CO2燃煤脱硫脱硝性能优于醋酸钙。O2/CO2燃煤烟气中喷入木醋调质石灰石、钙硫比为2.0、停留时间为0.8 s、在1 223和1 323 K时获得最大脱硫效率和最大脱硝效率为75.8%和86.6%。在上述条件下将氨气喷入反应区,氨氮比为0.75、温度为1 223和1 323 K时,脱硫效率分别为73.2%和63.9%,脱硝效率分别为93.2%和94.8%。
    Abstract: The performance of simultaneous desulfurization and denitration during coal combustion in O2/CO2 atmosphere with premixed and injected limestone modified by wood vinegar (LMWV) was investigated in a tube furnace and a drop tube furnace, respectively. The SO2 and NO reduction efficiency are 91.0%~94.9% and 23.5%~30.8% respectively during the combustion of coal premixed with LMWV at 1 173 ~ 1 323 K at the Ca/S molar ratio of 2.0. The desulfurization and denitration rates increase with raising the Ca/S molar ratio, and the optimum Ca/S molar ratio is from 1.5 to 2.0. The higher the sulfur content of coal, the greater desulfurization and denitration rates are gained during coal combustion. The performance of desulfurization and denitration with LMWV is better than that with calcium acetate. The maximum desulfurization and denitration rates of 75.8% and 86.6% respectively are gained by injecting LMWV directly into the flue gas of O2/CO2 coal combustion at both 1 223 K and 1 323 K and the Ca/S molar ratio of 2.0 with a residence time of 0.8 s. When the ammonia is injected into the reactive zone at [NH3]/[NO] molar ratio of 0.75, the desulfurization rates are 73.2% and 63.9%, and the denitration rates are 93.2% and 94.8%, respectively at the combustion temperature of 1 223 K and 1 323 K.
    • HTML全文
    • 参考文献(17)
  • CHENG J, ZHOU J H, LIU J Z, ZHOU Z J, HUANG Z Y, CAO X Y, ZHAO X, CEN K F. Sulfur removal at high temperature during coal combustion in furnaces: A review[J]. Prog Energy Combust Sci, 2003, 29(5): 381-405.
    ANTHONY E J, BULEWICZ E M, JIA L. Reactivation of limestone sorbents in FBC for SO2 capture [J]. Prog Energy Combust Sci, 2007, 33(2): 171-210.
    毛玉如, 方梦祥, 王勤辉, 吴学成, 骆仲泱, 倪明江, 岑可法. O2/CO2气氛下循环流化床煤燃烧污染物排放的试验研究[J]. 动力工程, 2004, 24(3): 411-415. (MAO Yu-ru, FANG Meng-xiang, WANG Qin-hui, WU Xue-cheng, LUO Zhong-yang, NI Ming-jiang, CEN Ke-fa. Experimental research on pollutant emission of coal combustion in a circulating fluidized bed test-facility under O2/CO2 atmosphere[J]. Power Engineering, 2004, 24(3): 411-415.)
    邹春, 黄志军, 初琨, 桂许龙, 丘纪华, 张立麒, 郑楚光. 燃煤O2/CO2循环燃烧过程中SO2与NOx协同脱除中试研究[J]. 中国电机工程学报, 2009, 29(2): 20-24. (ZOU Chun, HUANG Zhi-jun, CHU Kun, GUI Xu-long, QIU Ji-hua, ZHANG Li-lin, ZHENG Chu-guang. A pilot scale study on SO2 and NOx emission control in O2/CO2 recycled coal combustion[J]. Proceedings of the CSEE, 2009, 29(2): 20-24.)
    段伦博, 周骛, 屈成锐, 陈晓平, 赵长遂. O2/CO2气氛下循环流化床煤燃烧SO2排放[J]. 工程热物理学报, 2012, 33(1): 151-154. (DUAN Lun-Bo, ZHOU Wu, QU Cheng-Rui, CHEN Xiao-ping, ZHAO Chang-sui. SO2 emission from a coal-fired circulating fluidized bed combustor under O2/CO2 atmosphere[J]. Journal of Engineering Thermophysics, 2012, 33(1): 151-154.)
    武卫芳, 赵长遂, 李英杰, 段伦博, 陈惠超. O2/CO2气氛下醋酸调质石灰石直接硫化实验研究[J]. 中国电机工程学报, 2010, 30(26): 44-49. (WU Wei-fang, ZHAO Chang-sui, LI Ying-jie, DUAN Lun-bo, CHEN Hui-chao. Experimental investigation on direct sulphation characteristics of limestone modified by acetic acid solution under O2/CO2 atmosphere[J]. Proceedings of the CSEE, 2010, 30(26): 44-49.)
    PATSIAS A A, NIMMO W, GIBBS B M, WILLIAMS P T. Calcium-based sorbents for simultaneous NOx/SOx reduction in a down-fired furnace[J]. Fuel, 2005, 84(14/15): 1864-1873.
    肖海平. 有机钙同时脱硫脱硝的机理研究[D]. 杭州: 浙江大学, 2006. (XIAO Hai-ping. Mechanism study of simultaneously control of SO2 and NOx emissions with organic calcium[D]. Hangzhou: Zhejiang University, 2006.)
    刘洪涛, 牛胜利, 韩奎华, 路春美. 丙酸钙高温协同脱硫脱硝的试验研究[J]. 煤炭学报, 2010, 35(5): 835-839. (LIU Hong-tao, NIU Sheng-li, HAN Kui-hua, LU Chun-mei. Experimental study on the high-temperature capture of SO2 and NOx by calcium propionate[J]. Journal of China Coal Society, 2010, 35(5): 835-839.)
    NIU S L, HAN K H, ZHAO J L, LU C M. Experimental study on nitric oxide reduction through calcium propionate reburning[J]. Energy, 2011, 36(2): 1003-1009.
    牛胜利. 有机钙盐协同脱除SO2和NO的实验研究与机理分析[D]. 济南: 山东大学, 2011. (NIU Shen-gli. A study on dual reduction of SO2 and NO by calcium based organic compounds through experimental investigation and mechanism analysis[D]. Jinan: Shandong University, 2011.)
    刘洪涛, 韩奎华, 刘梦琪, 李辉, 路春美, 李刚. 木醋调质石灰石脱硫脱硝及助燃特性实验研究[J], 煤炭学报, 2012, 37(S2): 466-471. (LIU Hong-tao, HAN Kui-hua, LIU Meng-qi, LI Hui, LU Chun-mei, LI Gang. Experimental study on desulfurization, denitrification and combustion-supporting characteristics of limestone modified by wood vinegar[J]. Journal of China Coal Society, 2012, 37(S2): 466-471.)
    刘洪涛, 韩奎华, 李辉, 刘梦琪, 路春美. 木醋调质石灰石固硫性能的动力学研究[J]. 煤炭学报, 2012, 37(11): 1915-1919. (LIU Hong-tao, HAN Kui-hua, LI Hui, LIU Meng-qi, LU Chun-mei. Kinetic analysis on sulfation of limestone modified by wood vinegar[J]. Journal of China Coal Society, 2012, 37(11): 1915-1919.)
    刘洪涛, 韩奎华, 路春美, 李辉. O2/CO2气氛下木醋调质石灰石再燃/先进再燃脱硝性能研究[J]. 燃料化学学报, 2013, 41(2): 228-234. (LIU Hong-tao, HAN Kui-hua, LU Chun-mei, LI Hui. Experimental study on reburning/advanced reburning performance of limestone modified by wood vinegar for NO reduction under O2/CO2 atmosphere[J]. Journal of Fuel Chemistry and Technology, 2013, 41(2): 228-234.)
    刘洪涛, 韩奎华, 路春美. O2/CO2气氛下木醋调质石灰石直接硫化反应动力学研究[J]. 燃料化学学报, 2012, 40(12): 1505-1511. (LIU Hong-tao, HAN Kui-hua, LU Chun-mei. Kinetic study on direct sulfation reaction of limestone modified by wood vinegar under O2/CO2 atmosphere[J]. Journal of Fuel Chemistry and Technology, 2012, 40(12): 1505-1511.)
    侯祥松, 李金平, 张海, 赵石铁, 吕俊复, 岳光溪. 石灰石脱硫对循环流化床中NOx生成和排放的影响[J]. 电站系统工程, 2005, 27(1): 5-7, 16. (HOU Xiang-song, LI Jin-ping, ZHANG Hai, ZHAO Shi-tie, LV Jun-fu, YUE Guang-xi. Limestone effects on NOx formation & emission in CFB Combustors[J]. Power System Engineering, 2005, 27(1): 5-7, 16.)
    HAMPARTSOUMIAN E, NIMMO W, GIBBS B M. Nitrogen sulphur interactions in coal flames[J]. Fuel, 2001, 80(7): 887-897.
    • 相关文章
    • 施引文献
  • 资源附件(0)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2412
  • HTML全文浏览量:  21
  • PDF下载量:  590
  • 被引次数: 0
出版历程
  • 收稿日期:  2013-03-09
  • 修回日期:  2013-05-26
  • 刊出日期:  2013-11-30

目录

    /

    返回文章
    返回
    友情链接： 新型炭材料 中国科学院 中国知网 万方论文查重系统

    主办单位：中国科学院山西煤炭化学研究所 中国化学会主编：房倚天

    电子邮件：rlhx@sxicc.ac.cn

    版权所有 © 《燃料化学学报（中英文）》编辑部 本系统由 北京仁和汇智信息技术有限公司 开发    百度统计

    x 关闭 永久关闭

    2023年《燃料化学学报（中英文）》评优结果公布！