生物质高级再燃脱硝的影响因素与元素释放特性

郝江涛; 于伟; 卢平; 王秦超; 何楠; 祝秀明; 徐森荣

生物质高级再燃脱硝的影响因素与元素释放特性

1.
南京师范大学能源与机械工程学院, 江苏南京 210042;
2.
南京凯盛开能环保能源有限公司, 江苏南京 210036

基金项目: 国家自然科学基金（51076067）；江苏省自然科学基金（BK2010081）。

详细信息

通讯作者:
卢平（1968- ），男，江苏南京人，博士，教授，从事能源清洁利用与污染物控制的研究，Email：luping@njnu.edu.cn。

中图分类号: TK229.6;X701
计量
- 文章访问数: 780
- HTML全文浏览量: 22
- PDF下载量: 480
- 被引次数: 0
出版历程
- 收稿日期: 2013-12-02
- 修回日期: 2014-02-20
- 刊出日期: 2014-05-30

Influence factors and element release properties during NO reduction through biomass advanced reburning

1.
School of Energy & Mechanical Engineering, Nanjing Normal University, Nanjing 210042, China;
2.
Nanjing Triumph Kaineng Environmental Protection & Energy Co., Ltd., Nanjing 210036, China

摘要

摘要: 以稻壳（RH）、梧桐叶（PTL）和木屑（SD）为对象，利用携带流脱硝实验装置，研究了生物质种类、再燃反应温度（t₂）、再燃区化学计量比（SR₂）、喷氨位置、水蒸气以及添加剂等对生物质高级再燃（AR）脱硝效率的影响，分析了高级再燃过程中钾和氯等元素的释放特性。结果表明，在t₂为850~1 150 ℃，随着t₂升高，生物质高级再燃脱硝效率呈现先上升后下降的趋势。在SR₂为0.5~1.0，随着SR₂增加，稻壳高级再燃脱硝效率呈现先增加后降低的趋势。停留时间为0.4~1.0 s，氨气添加位置对稻壳高级再燃脱硝效率有一定的影响，但其效果并不明显。烟气中水蒸气含量（0~15%）可提高稻壳高级再燃的脱硝效率，而且可拓宽脱硝温度窗口。不同再燃温度下，4%水蒸气含量模拟烟气的脱硝效率最大。添加剂（Fe₂O₃、KCl、NaCl和CaO）对稻壳高级再燃脱硝均有促进作用，其中，Fe₂O₃促进作用最为显著。在稻壳高级再燃过程中，氯和钾元素释放率分别达到95.0%和59.8%以上。
- 生物质 /
- 高级再燃 /
- 脱硝 /
- 添加剂 /
- 元素释放
Abstract: NO reduction through advanced reburning (AR) with biomass including rice husk (RH), phoenix tree leaves (PTL) and saw dust (SD) was tested in an entrained flow reactor (EFR). The effects of reburning fuel species, reaction temperature in the reburning-zone (t₂), the location of ammonia injection, water vapor and additives on the NO reduction were investigated. Furthermore, the migration of chloride and potassium elements during biomass advanced reburning was examined. The results indicate that the NO removal efficiency via biomass advanced reburning shows a tendency of increase first and decrease later with increasing the reaction temperature in the reburning-zone from 850 ℃ to 1 150 ℃. The same tendency is also found as SR₂ increases from 0.5 to 1.0. The location of ammonia injection has a certain influence on the NO reduction with rice husk when the residence time is in the range of 0.4~1.0 s. The water vapor (0~15%) in the flue gas not only improves the NO removal efficiency, but also broadens the window temperature of DeNO_x, and the best NO removal efficiency can be obtained when the water vapor is about 4%. Additives (Fe₂O₃, KCl, NaCl and CaO) have a better promoting effects on the NO reduction through advanced reburning with rice husk, in which Fe₂O₃ shows the most significant effect on the NO reduction. The release of chlorine and potassium during advanced reburning with rice husk can reach more than 95.0% and 59.8%, respectively.
- biomass /
- advanced reburning /
- NO removal /
- additives /
- element release

HTML全文

参考文献(29)

HARDING N S, BRADLEY R A. Biomass as a reburning fuel: A specialized cofiring application[J]. Biomass Bioenergy, 2000, 19(6): 429-445.

段佳, 罗永浩, 晏乃强, 陈祎, 陆方, 王清成. 生物质气化再燃特性实验研究[J]. 燃料化学学报, 2007, 35(2): 245-248. (DUAN Jia, LUO Yong-hao, YAN Nai-qiang, CHEN Yi. LU Fang, WANG Qing-cheng. Experimental study on characteristics of biomass gasification-reburning[J]. Journal of Fuel Chemistry and Technology, 2007, 35(2): 245-248.)

王永桥, 陆飞, 刘永生, 卢平. 生物质再燃脱硝及异相还原研究[J]. 中国电机工程学报, 2010, 30(26): 101-106. (WANG Yong-qiao, LU Fei, LIU Yong-sheng, LU Ping. Study on NO_x reduction and its heterogeneous mechanism during biomass reburning[J]. Proceedings of the CSEE, 2010, 30(26): 101-106.)

王秦超, 卢平, 黄震, 亓海明, 李臣良. 生物质炭再燃脱硝特性的实验研究[J]. 动力工程学报, 2013, 33(4): 296-302. (WANG Qin-chao, LU Ping, HUANG Zhen, QI Hai-ming, LI Chen-liang. Experimental studies on NO reduction by reburning with biomass char[J]. Chinese Society of Power Engineering, 2013, 33(4): 296-302.)

高攀, 路春美, 甄天雷, 刘磊. 高级再燃气体脱硝特性的研究[J]. 燃料化学学报, 2007, 35(5): 632-636. (GAO Pan, LU Chun-mei, ZHEN Tian-lei, LIU Lei. Study on NO reduction by advanced gas reburning[J]. Journal of Fuel Chemistry and Technology, 2007, 35(5): 632-636.)

刘洪涛, 韩奎华, 路春美, 李辉. O₂/CO₂气氛下木醋调质石灰石再燃/先进再燃脱硝性能研究[J]. 燃料化学学报, 2013, 41(2): 228-233. (LIU Hong-tao, HAN Kui-hua, LU Chun-mei, LI Hui. Experimental study on reburning/advanced reburning performance of limestone modified by wood vinegar for NO reduction under O₂/CO₂ atmosphere[J]. Journal of Fuel Chemistry and Technology, 2013, 41(2): 228-233.)

HAN K, NIU S, LU C. Experimental study on biomass advanced reburning for nitrogen oxides reduction[J]. Process Saf Environ, 2010, 88(6): 425-430.

GROSS R, LEACH M, BAUEN A. Progress in renewable energy[J]. Environ Int, 2003, 29(1): 105-122.

牛胜利, 韩奎华, 路春美. 生物质先进再燃脱硝特性研究[J]. 燃料化学学报, 2010, 38(6): 746-751. (NIU Sheng-li, HAN Kui-hua, LU Chun-mei. Study on nitrogen oxides reduction by biomass advanced reburning process[J]. Journal of Fuel Chemistry and Technology, 2010, 38(6): 746-751.)

沈伯雄, 孙幸福. 水蒸气对先进再燃区脱硝效率的影响研究[J]. 电站系统工程, 2006, 22(1): 41-43. (SHEN Bo-xiong, SUN Xing-fu. Experimental study on advanced reburning to De-NO_x under high temperature[J]. Power System Engineering, 2006, 22(1): 41-43.)

LEE S, PARK K, PARK J, KIM B. Characteristics of reducing NO using urea and alkaline additives[J]. Combust Flame, 2005, 138(2): 200-203.

MALY P M, ZAMANSKY V M, HO L, PAYNE R. Alternative fuel reburning[J]. Fuel, 1999, 78(3): 327-334.

陈安和, 杨学民, 林伟刚. 生物质热解和气化过程Cl及碱金属逸出行为的化学热力学平衡分析[J]. 燃料化学学报, 2007, 35(5): 539-547. (CHEN An-he, YANG Xue-min, LIN Wei-gang. Release characteristics of chlorine and alkali metals during pyrolysis and gasification of biomass by thermodynamical equilibrium analysis[J]. Journal of Fuel Chemistry and Technology, 2007, 35(5): 539-547.)

JOHANSEN J M, AHO M, PAAKKINEN K, TAIPALE R, EGSGAARD H, JAKOBSEN J G, FRANDSEN F J, GLARBORG P. Release of K, Cl, and S during combustion and co-combustion with wood of high-chlorine biomass in bench and pilot scale fuel beds[J]. Pro Combust Inst, 2013, 34(2): 2363-2372.

付世龙, 宋蔷, 仲蕾, 姚强. 粉体对分解炉内SNCR反应影响的研究[J]. 燃料化学学报, 2013, 41(5): 636-640. (FU Shi-long, SONG Qiang, ZHONG Lei, YAO Qiang. Influence of calcium-based particles on the selective non-catalytic reduction process in a pre-calciner[J]. Journal of Fuel Chemistry and Technology, 2013, 41(5): 636-640.)

LU P, WANG YQ, HUANG Z, LU F, LIU Y. Study on NO reduction and its heterogeneous mechanism through biomass reburning in an entrained flow reactor[J]. Energy Fuels, 2011, 25(7): 2956-2962.

RUDIGER H, KICHERER A, GREUL U, SPLIETHOFF H, HEIN K R. Investigations in combined combustion of Biomass and coal in power plant technology[J]. Energy Fuels, 1996, 10(3): 789-796.

ZAMANSKY V M, MALY P M, LISSIANSKI V V, SHELDON M S, MOYEDA D, PAYNE R. Second generation advanced reburning for high efficiency NO_x control: Final Report[R]. DE-AC22-95PC95251, 2001.

ZHONG B J, SHI W W, FU W B. Effects of fuel characteristics on the NO reduction during the reburning with coals[J]. Fuel Process Technol, 2002, 79(1): 93-106.

林晓芬, 张军, 尹艳山, 盛昌栋. 生物质炭孔隙分形特征研究[J]. 生物质化学工程, 2009, 43(3): 9-12. (LIN Xiao-fen, ZHANG Jun, YIN Yan-shan, SHENG Chang-dong. Study on fractal characteristics of biomass chars[J]. Biomass Chemical Engineering, 2009, 43(3): 9-12.)

KILPINEN P, GLARBORG P, HUPA M. Reburning chemistry: A kinetic modeling study[J]. Ind Eng Chem Res, 1992, 31(6): 1477-1490.

JAVED M T, IRFAN M, GIBBS B M. Control of combustion-generated nitrogen oxides by selective non-catalytic reduction[J]. Environ Manage, 2007, 83(3): 251-298.

LISSIANSKI V V, MALY P M. Utilization of iron additives for advanced control of NO_x emissions from stationary combustion sources[J]. Ind Eng Chem Res. 2001, 40(15): 3287-3293.

苏亚欣, 邓文义, 苏阿龙. 甲烷在氧化铁表面还原NO 的特性与反应机理研究[J]. 燃料化学学报, 2013, 41(9): 1129-1135. (SU Ya-xin, DENG Wen-yi, SU A-long. NO reduction by methane over iron oxides and the mechanism[J]. Journal of Fuel Chemistry and Technology, 2013, 41(9): 1129-1135.)

ZAMANSKY V M, LISSIANSKI V V, MALY PM, HO L, RUSLI D, GARDINER W C. Reactions of sodium species in the promoted SNCR process[J]. Combust Flame, 1999, 117(4): 821-831.

LISSIANSKI V V, ZAMANSKY V M, MALY P M. Effect of metal-containing additives on NO_x reduction in combustion and reburning[J]. Combust Flame, 2001, 125(3): 1118-1127.

WEI X L, SCHNELL U, HEIN K R G. Behavior of gaseous chlorine and alkali metals during biomass thermal utilization[J]. Fuel, 2005, 84(7/8): 841-848.

窦沙沙, 何芳, 王丽红, 易维明. 玉米秸秆热解挥发分元素含量分析[J]. 可再生能源, 2006, (5): 22-24. (DOU Sha-sha, HE Fang, WANG Li-hong, YI Wei-ming. Elemental content of volatiles from corn stalk pyrolysis[J]. Renewable Energy, 2006, (5): 22-24.)

NIU Y, DU W, TAN H, XU W, LIU Y, XIONG Y, HUI S. Further study on biomass ash characteristics at elevated ashing temperatures: The evolution of K, Cl, S and the ash fusion characteristics[J]. Bioresource Technol, 2013, 129: 642-645.

施引文献

资源附件(0)

访问统计