润湿剂促进燃煤细颗粒声波团聚脱除的实验研究

颜金培; 陈立奇; 杨林军

润湿剂促进燃煤细颗粒声波团聚脱除的实验研究

1.
国家海洋局海洋-大气化学与全球变化重点实验室国家海洋局第三海洋研究所, 福建厦门 361005;
2.
东南大学能源与环境学院, 江苏南京 210096

基金项目: 国家自然科学基金(21106018); 国家海洋局青年海洋科学基金(2013534)。

详细信息

通讯作者:
颜金培(1981- ),男,福建泉州人,博士,主要从事燃煤大气污染控制及大气气溶胶研究。 E-mail:jpyan@tio.org.cn。

中图分类号: X51
计量
- 文章访问数: 762
- HTML全文浏览量: 15
- PDF下载量: 727
- 被引次数: 0
出版历程
- 收稿日期: 2014-06-25
- 修回日期: 2014-08-29
- 刊出日期: 2014-10-30

Experimental study on promotion of coal combustion fine particles acoustic agglomeration removal by using wetting agents

1.
Key Laboratory of Global Change and Marine-Atmospheric Chemistry, Third Institute of Oceanography, SOA, Xiamen 361005, China;
2.
School of Energy and Environment, Southeast University, Nanjing 210096, China

摘要

摘要: 在声波团聚室中研究了润湿剂液滴与细颗粒碰撞团聚脱除特性,提出了一种利用润湿剂促进细颗粒在声波场中捕集的新方法。结果表明,不同润湿剂溶液对细颗粒在声波场中的团聚脱除效果存在较大差异,采用JFC和FS-310润湿剂溶液时,细颗粒分级脱除效率与采用水时的分级脱除效率相近。而SDS和Silanol w22溶液,则可有效提高细颗粒在各粒径段的分级脱除效率。细颗粒在声波场中的脱除效率与润湿剂润湿性能具有很好的相关性,随润湿剂对细颗粒相对接触角增大而降低,在声压级为150 dB时,相对接触角由83°降低到0°,细颗粒脱除效率提高了18%,在无声场作用下,脱除效率仅提高了5%。细颗粒脱除效率随声压级的增大而提高,在低声压级条件下,添加润湿剂可有效提高细颗粒脱除效率,声压级在130 dB时,添加SDS溶液液滴后细颗粒脱除效率比声场单独作用时的脱除效率提高了25%。表明添加润湿剂可有效提高细颗粒在声波场中的团聚脱除效率,实现在低声压级条件下,获得高的细颗粒脱除效率。
- 细颗粒 /
- 声波 /
- 团聚 /
- 润湿剂 /
- 脱除
Abstract: The characteristics of agglomeration removal between wetting agent droplets and fine particles were investigated in an acoustic agglomeration chamber. A novel technique using wetting agents to promote the fine particle capture by acoustic agglomeration was presented. The experimental results show that the type of wetting agent has a significant effect on the acoustic agglomeration of fine particles. The particle stage removal efficiencies using JFC and FS-310 are similar to that using plain water droplets, but the removal efficiencies by SDS and Silanol w22 are much higher than that using water droplets. Fine particle removal efficiency in the acoustic field correlates well with the wettability of wetting agents, which decreases with increasing the relative contact angle of wetting agents. While the relative contact angle descends from 83° to 0°, the removal efficiency of fine particles with sound pressure level of 150 dB increases by about 18%. However, the removal efficiency of fine particle without acoustic effects only increases by about 5%. Higher sound pressure level can improve the particle removal efficiency that is extremely low when the sound pressure level is below 150 dB. However it can be improved with wetting agents addition to the atomization droplets. The capture efficiency can be increased by 25% with SDS adding than acoustic effect only under the sound pressure level of 130 dB. It indicates that the removal of fine particles is effectively improved by using wetting agents with acoustic wave agglomeration, and the high removal efficiency can be achieved at a low sound pressure level.
- fine particles /
- acoustic wave /
- agglomeration /
- wetting agent /
- removal

HTML全文

参考文献(23)

SUN Y L, ZHUNG G S, TANG A H, WANG Y, AN Z S. Chemical characteristics of PM_2.5 and PM₁₀ in haze-fog episodes in Beijing[J]. Environ Sci Technol, 2006, 40(10): 3148-3155.

GAO J, WANG T, ZHOU X H, WU W S, WANG W X. Measurement of aerosol number size distributions in the Yangtze River delta in China: Formation and growth of particles under polluted conditions[J]. Atmos Environ, 2009, 43(4): 829-836.

张小曳, 孙俊英, 王亚强, 李卫军, 张蔷, 王炜罡, 权建农, 曹国良, 王继志, 杨元琴, 张养梅. 我国雾-霾成因及其治理的思考[J]. 科学通报, 2013, 58(13): 1178-1187. (ZHANG Xiao-ye, SUN Jun-ying, WANG Ya-qiang, LI Wei-jun, ZHANG Qiang, WANG Wei-gang, QUAN Jian-nong, CAO Guo-liang, WANG Ji-zhi, YANG Yuan-qin, ZHANG Yang-mei. Factors contributing to haze and fog in China[J]. China Science Bull, 2013, 58(13): 1178-1187.)

赵永椿, 张军营, 魏凤, 陈俊, 郑楚光. 燃煤超细颗粒物团聚促进机制的实验研究[J]. 化工学报, 2007, 58(11): 2876-2881. (ZHAO Yong-chun, ZHANG Jun-ying, WEI Feng, CHEN Jun, ZHENG Chu-guang. Experimental study on agglomeration of submicron particles from coal combustion[J]. Journal of Chemical Industry and Engineering, 2007, 58(11): 2876-2881.)

颜金培, 杨林军, 张霞, 孙露娟, 张宇, 沈湘林. 应用蒸汽相变机理脱除燃煤可吸入颗粒物实验研究[J]. 中国电机工程学报, 2007, 35(27): 12-16. (YAN Jin-pei, YANG Lin-jun, ZHANG Xia, SUN Lu-juan, ZHANG Yu, SHEN Xiang-lin. Experiment study on separation of inhalable particles from coal combustion by heterogeneous condensation enlargement[J]. Proceedings of the CSEE, 2007, 35(27): 12-16.)

REEFTHOF G. Acoustic agglomeration of power plant fly ash for environmental and hot gas clean-up[J]. J Vib Acoust, 1988, 110 (4): 552-557.

RIERA-FRANCO E S, GALLEGO-JUAREZ J A, RODRIGUEZ-CORRAL G L. Application of high-power ultrasound of enhances fluid/solid particle separation processes[J]. Ultrasonics, 2000, 38(5): 642-646.

HOFFMANN T L, CHEN W, KOOPMANN G H. Experimental and numerical analysis of bimodal acoustic agglomeration[J]. J Vib Acoust, 1993, 115(3): 232-240.

HOFFMANN T L, KOOPMANN G H. A new technique for visualization of acoustic particle agglomeration[J]. Am Ins Phy, 1994, 65(5): 1527-1536.

姚刚, 盛昌栋, 杨林军, 沈湘林. 燃烧超细颗粒声波团聚的谱分布数值模拟[J]. 燃烧科学与技术, 2005, 11(3): 273-277. (YAO Gang, SHENG Chang-dong, YANG Lin-jun, SHEN Xiang-lin. Spectrum evolution of combustion ultrafine particles acoustic agglomeration simulated by numerical algorism[J]. Journal of Combustion Science and Technology, 2005, 11(3): 273-277.)

赵兵, 陈厚涛, 徐进, 沈湘林. 声波与种子颗粒联合作用下细颗粒脱除的实验研究[J]. 动力工程, 2007, 27(5): 785-788. (ZHAO Bing, CHEN Huo-tao, XU Jin, SHEN Xiang-lin. Experimental study on precipitation of fine particles under the combined action of acoustic waves and seed particles[J]. Journal of Power Engineering, 2007, 27(5): 785-788.)

张光学, 刘建忠, 周俊虎, 王洁, 岑可法. 频率对燃煤飞灰声波团聚影响的模型研究及实验验证[J]. 中国电机工程学报, 2009, 29(17): 97-102. (ZHANG Guang-xue, LIU Jian-zhong, ZHOU Jun-hu, WANG Jie, CEN Ke-fa. A theoretical model and experimental verification on the influence of frequency on acoustic agglomeration of coal-fired fly ash[J]. Proceedings of the CSEE(China), 2009, 29(17): 97-102.)

陈厚涛. 声波团聚增强燃烧源细颗粒物排放控制的研究[D]. 南京: 东南大学, 2009. (CHEN Hou-tao. Study on the enhancement of emission control of fine particles from combustion by acoustic agglomeration[D]. Nanjing: Southeast University, 2009.)

陈厚涛, 赵兵, 章汝心, 曹金祥, 沈湘林. 声波与雾化水滴联合作用增强燃煤PM_2.5脱除的实验研究[J]. 中国电机工程学报, 2009, 29(2): 35-40. (CHEN Huo-tao, ZHAO Bing, ZHANG Ru-xin, CAO Jin-xiang, SHEN Xiang-lin. Experimental study on the enlargement of removing PM_2.5 in coal-fired fumes under the combined effect of acoustic wave and atomized water drop[J]. Proceedings of the CSEE, 2009, 29(2): 35-40.)

王洁, 张光学, 刘建忠, 周俊虎, 岑可法. 种子颗粒对声波团聚效率的影响[J]. 化工学报, 2011, 62(2): 355-361. (WANG Jie, ZHANG Guang-xue, LIU Jian-zhong, ZHOU Jun-hu, CEN Ke-fa. Effect of seed particles on acoustic agglomeration efficiency[J]. Journal of Chemical Industry and Engineering, 2011, 62(2): 355-361.)

CHEN Y Y, LEE W G. Hygroscopic properties of inorganic-salt aerosol with surface-active organic compounds[J]. Chemosphere, 1999, 38(10): 2431-2448.

WEINGARTNER E, BURTSCHER H, BALTENSPERGER U. Hygroscopic properties of carbon and diesel soot particles[J]. Atmos Environ, 1997, 31(15): 2311-2327.

KERMINEN V M. The effects of particle chemical character and atmospheric processes on particle hygroscopic properties[J]. J Aerosol Sci, 1997, 28(1): 121-132.

SCHABE K, KORBER J, OFENLOCH O, EHRIG R, DEUFLHARD P. Aerosol formation in gas-liquid contact devices-nucleation, growth and particle dynamics[J]. Chem Eng Sci, 2002, 57(20): 4345-4356.

MIKHAILOV E F, VLASENKO S S, LUTZ K, REINHARD N. Interaction of soot aerosol particles with water droplets: Influence of surface hydrophilicity[J]. J Aerosol Sci, 2001, 32(6): 697-711.

CLIVE A P, JOHN R. Contact angle studies of galena particles[J]. J Colloid Interface Sci, 1995, 172(2): 302-310.

颜金培, 杨林军, 沈湘林. 燃烧源PM_2.5微粒润湿性能[J]. 东南大学学报(自然科学板), 2006, 36(5): 760-764. (YAN Jin-pei, YANG Lin-jun, SHEN Xiang-lin. Wettability of PM_2.5 from combustion[J]. Journal of Southeast University(Natural Science Edition), 2006, 36(5): 760-764.)

CHYLEK P, VIDEEN G, NGO D, PINNICK R G, KLETT J D. Effect of black carbon on the optical properties and climate forcing of sulfate aerosols[J]. J Geophys Res, 1995, 100(D8):16325-16332.

施引文献

资源附件(0)

访问统计