Effect of particle size distribution on the properties of petroleum coke water slurry
-
摘要: 分析研究了不同粒径分布的石油焦成浆性及制备水焦浆的流变性和稳定性。结果表明,石油焦的成浆性较好,成浆浓度近70%,浆体的表观黏度均随浓度的增大而增大。粒径分布越宽,越有利于堆积,堆积效率越高,可制浆浓度越高,制备水焦浆的最佳药剂量越低,采用萘系分散剂制备的水焦浆呈胀塑性流型,粒径分布越宽,胀塑性越弱,利用静置观察法与Turbiscan Lab稳定性分析仪测定相结合评价水焦浆的稳定性,水焦浆的稳定性差,且粒径越大,析水率越低,沉降区的焦粉颗粒越易发生聚结,底部越易产生硬沉淀,稳定性越差。颗粒聚结是水焦浆稳定性的主要影响因素。Abstract: The slurryability, rheological characteristics and stability of petroleum coke water slurry (PCWS) with different particle size distribution were studied. The results show that the slurryability of petroleum coke was good, and the solid concentration was about 70%. The apparent viscosity of PCWS increases with the petroleum coke concentration increase. The PCWS with wider particle size distribution has the better close-packing and higher stacked efficiency, which results in the higher solid concentration with fewer dispersants. The PCWS behaves as a dilatant fluid with naphthalene series dispersant. The dilatability decreases with the wide distribution of particle size. The stability of PCWS is evaluated by using standing observation and Turbiscan Lab stability analyzer methods. When the particle size is larger, the stability of PCWS is worse, the drainage rate is lower, and the petroleum coke particle coalescence and hard sedimentation are easy formation. Particle coalescence is the main factor influencing the stability of PCWS.
-
Key words:
- petroleum coke /
- PCWS /
- particle size distribution /
- slurryability /
- rheological characteristics /
- stability /
- coalescence
-
赵冰, 周志杰, 丁路, 于广锁. 快速热处理石油焦与煤的微观结构变化及气化活性分析[J]. 燃料化学学报, 2013, 41(1): 40-45. (ZHAO Bing, ZHOU Zhi-jie, DING Lu, YU Guang-suo. Changes in the microstructure and gasification reactivity of petroleum coke and coal samples after rapid pyrolysis[J]. J Fuel Chem Technol, 2013, 41(1): 40-45.) 柳宇, 许桂英, 宋健斐, 吴桂英, 孙国刚. 石油焦对生物质气化中焦油裂解的影响[J].化工学报, 2010, 61(9): 2494-2498. (LIU Yu, XU Gui-ying, SONG Jian-fei, WU Gui-ying, SUN Guo-gang. Effect of petroleum coke on tar cracking in biomass gasification process[J]. CIESC J, 2010, 61(9): 2494-2498.) 高夫燕, 刘建忠, 王传成, 虞育杰, 程军, 张彦威, 周俊虎, 岑可法. 石油焦的成浆性及水焦浆的流变性和稳定性[J]. 化工学报, 2010, 61(11): 2912-2918. (GAO Fu-yan, LIU Jian-zhong, WANG Chuan-cheng, YU Yu-jie, CHENG Jun, ZHANG Yan-wei, ZHOU Jun-hu, CEN Ke-fa. Slurryability of petroleum coke and rheological characteristics and stability of PCWS[J]. CIESC J, 2010, 61(11): 2912-2918.) 王贵金, 郭大亮, 袁洪友, 周肇秋, 阴秀丽, 吴创之. 黑液与石油焦共热解及其产物特性研究[J]. 燃料化学学报, 2014, 42(5): 545-551. (WANG Gui-jin, GUO Da-liang, YUAN Hong-you, ZHOU Zhao-qiu, YIN Xiu-li, WU Chuang-zhi. Co-pyrolysis behaviors and products characteristics of black liquor and petroleum coke[J]. J Fuel Chem Technol, 2014, 42(5): 545-551.) 纪丽媛, 黄胜, 吴诗勇, 吴幼青, 高晋生. 原煤与石油焦共气化反应特性[J]. 石油学报(石油加工), 2014, 30(3): 493-500. (JI Li-yuan, HUANG Sheng, WU Shi-yong, WU You-qing, GAO Jin-sheng. Co-gasification characteristics of petroleum coke and coal[J]. Acta Pet Sini (Pet Proc Sect), 2014, 30(3): 493-500.) 杨国军. 水焦浆的制备及应用[J]. 煤炭加工与综合利用, 2008, (3): 33-35. (YANG Guo-jun. Preparation and application of PCWS[J]. Coal Process Compr Util, 2008, (3): 33-35.) 展秀丽, 刘鑫, 徐少特, 贾佳, 周志杰, 王辅臣. 灰渣对石油焦浆稳定性的影响研究[J]. 化学工程, 2010, 38(3): 86-90. (ZHAN Xiu-li, LIU Xin, XU Shao-te, JIA Jia, ZHOU Zhi-jie, WANG Fu-chen. Effect of coal slag on stability of petroleum coke water slurry[J].Chem Eng (China), 2010, 38(3): 86-90.) GAO F Y, LIU J Z, ZHOU J H, CEN K F. Preparation and improving stability of bubble petroleum coke water slurry[J]. Fuel, 2014, 128: 404-409. 黄冰冰, 刘猛, 段钰锋, 陈高森, 马贵林, 王素美. 污泥增强水焦浆稳定性的机制及理论分析[J]. 中国电机工程学报, 2014, 34(17): 2747-2752. (HUANG Bing-bing, LIU Meng, DUAN Yu-feng, CHEN Gao-sen, MA Gui-lin, WANG Su-mei. Mechanism and theoretical analysis on stability of petroleum coke-water slurry enhanced by sewage sludge[J]. Proc CSEE, 2014, 34(17): 2747-2752.) 张荣曾. 水煤浆制浆技术[M]. 北京: 科学出版社, 1996. (ZHANG Rong-zeng. Preparation technique of CWS[M]. Beijing: Science Press, 1996.) 朱书全, 邹立壮, 黄波, 崔广文, 王奇. 水煤浆添加剂与煤之间的相互作用规律研究Ⅰ.复合煤颗粒间的相互作用对水煤浆流变性的影响[J]. 燃料化学学报, 2003, 31(6): 519-524. (ZHU Shu-quan, ZOU Li-zhuang, HUANG Bo, CUI Guang-wen, WANG Qi. Study on the interaction characteristics between different CWS dispersants and coals Ⅰ. Effect of the interaction of complex coal particle on CWS rheological behavior[J]. J Fuel Chem Technol, 2003, 31(6): 519-524.) 尉迟唯, 李保庆, 李文, 陈皓侃. 煤质因素对水煤浆性质的影响[J]. 燃料化学学报, 2007, 35(2): 146-154. (YU Chi-wei, LI Bao-qing, LI Wen, CHEN Hao-kan. Analysis of coal characteristics on the properties of coal water slurry preparation with different coal ranks[J]. J Fuel Chem Technol, 2007, 35(2): 146-154.) 支献华. 水煤浆稳定性的影响因素及评定方法[J]. 煤炭加工与综合利用, 2000, (1): 38-39. (ZHI Xian-hua. The factors influencing the stability of coal water slurry and assessment methods[J]. Coal Process Compr Util, 2000, (1): 38-39.) 傅丛, 李英华, 孙刚. 水煤浆稳定性测定方法的研究和标准制定[J]. 洁净煤技术, 2002, 8(4): 20-23. (FU Cong, LI Ying-hua, SUN Gang. Study on stability measurement method of coal water mixture and its standard formulation[J]. Clean Coal Technol, 2002, 8(4): 20-23.) 李朋伟, 杨东杰, 楼宏铭, 邱学青. 利用分散稳定性分析仪研究水煤浆的稳定性[J]. 燃料化学学报, 2008, 36(5): 524-529. (LI Peng-wei, YANG Dong-jie, LOU Hong-ming, QIU Xue-qing. Study on the stability of coal water slurry using dispersion-stability analyzer[J]. J Fuel Chem Technol, 2008, 36(5): 524-529.) 孙美洁, 徐志强, 涂亚楠, 郑剑平, 楚天成, 王浩. 基于多重光散射原理的水煤浆稳定性分析研究[J]. 煤炭学报, 2015, 40(3): 659-664. (SUN Mei-jie, XU Zhi-qiang, TU Ya-nan, ZHENG Jian-ping, CHU Tian-cheng, WANG Hao. Research on the stability of CWS based on the multiple light scattering principle[J]. J Chin Coal Soc, 2015, 40(3): 659-664.) 黄翔峰, 程航, 陆丽君, 刘佳. 利用稳定性分析仪研究化学破乳过程[J]. 化工进展, 2010, 29(5): 825-830. (HUANG Xiang-feng, CHENG Hang, LU Li-jun, LIU Jia. Investigation of chemical demulsification process by stability analyzer[J]. Chem Ind Eng Prog, 2010, 29(5): 825-830.) 张小军, 冯建国, 刘尚钟, 吴学民. 利用多重光散射技术研究吡虫啉悬浮剂的物理稳定性[J]. 光谱学与光谱分析, 2013, 33(2): 423-427. (ZHANG Xiao-jun, FENG Jian-guo, LIU Shang-zhong, WU Xue-min. Physical stability of imidacloprid suspension concentrate studied by the multiple light scattering technique[J]. Spectrosc Spectral Anal, 2013, 33(2): 423-427.) 虞育杰, 刘建忠, 张传名, 赵卫东, 周俊虎, 岑可法. 低挥发分煤的成浆特性和水煤浆流变特性[J]. 浙江大学学报(工学版), 2011, 45(2): 335-340. (YU Yu-jie, LIU Jian-zhong, ZHANG Chuan-ming, ZHAO Wei-dong, ZHOU Jun-hu, CEN Ke-fa.Slurrying characteristics of low-volatile coal and the rheological characteristics of coal water slurry[J]. J Zhejiang Univ (Eng Sci), 2011, 45(2): 335-340.) 邹立壮, 朱书全, 王晓玲, 崔广文. 不同水煤浆分散剂与煤之间的相互作用规律研究(Ⅵ)分散剂对水煤浆静态稳定性的影响[J]. 煤炭转化, 2005, 28(2): 42-47. (ZOU Li-zhuang, ZHU Shu-quan, WANG Xiao-ling, CUI Guang-wen. Study on the interaction characteristics between different CWS dispersants and coals part (Ⅵ) effect of dispersants on the static stability of CWS[J]. Coal Convers, 2005, 28(2): 42-47.) 邹立壮, 朱书全, 支献华, 崔广文. 不同水煤浆添加剂与煤之间的相互作用规律研究—分散剂用量对水煤浆流变特性的影响(Ⅳ)[J].中国矿业大学学报, 2004, 33(4): 370-374. (ZOU Li-zhuang, ZHU Shu-quan, ZHI Xian-hua, CUI Guang-wen. Study of interaction features between different CWS dispersants and coals-effect of dispersant dosage on CWS rheological behavior(Ⅳ)[J]. J Chin Univ Min Technol, 2004, 33(4): 370-374.)
点击查看大图
计量
- 文章访问数: 478
- HTML全文浏览量: 39
- PDF下载量: 424
- 被引次数: 0