NaCl与Hg0对V2O5-WO3/TiO2SCR脱硝催化剂的协同作用研究

孔明; 刘清才; 赵冬; 任山; 孟飞

NaCl与Hg⁰对V₂O₅-WO₃/TiO₂SCR脱硝催化剂的协同作用研究

重庆大学材料科学与工程学院, 重庆市能源环境研究中心, 重庆 400044

基金项目: 国家自然科学基金(51274263,51204220)和重庆市自然科学基金(cstc2013jjB0035)资助项目

详细信息

通讯作者:
任山,Tel:13638394586,E-mail:shan.ren@cqu.edu.cn

中图分类号: X703.5
计量
- 文章访问数: 320
- HTML全文浏览量: 22
- PDF下载量: 313
- 被引次数: 0
出版历程
- 收稿日期: 2015-05-18
- 修回日期: 2015-07-21
- 刊出日期: 2015-12-30

Synergy of NaCl and Hg⁰ on V₂O₅-WO₃/TiO₂ SCR catalysts

Engineering Research Center for Energy and Environment of Chongqing, College of Materials Science and Engineering of Chongqing University, Chongqing 400044, China

Funds: The project was supported by the National Natural Science Foundation of China (51274263,51204220) and Natural Science Foundation of Chongqing (cstc2013jjB0035).

摘要

摘要: 制备了纳米级V₂O₅-WO₃/TiO₂脱硝催化剂,采用浸渍法模拟催化剂NaCl中毒,吸附法模拟单质汞Hg⁰作用于催化剂,运用X射线衍射分析(XRD)、扫描电镜(SEM)、比表面积分析(BET)、NH₃程序升温脱附(NH₃-TPD)、傅里叶变换红外光谱分析(FT-IR)等技术表征分析了NaCl和Hg⁰对催化剂性能的影响。同时,结合已有的研究分析,提出两者对催化剂的作用机理。实验结果表明,NaCl的添加会造成催化剂表面团聚黏结,催化剂比表面积减小,且NaCl负载量越大,对催化剂毒害作用越大。Na会中和催化剂的Brønsted酸性位(V-OH),最终形成-V-O-Na及Cl-V-O-Na,造成催化剂失活。Hg⁰对催化剂的表面形貌及物相组成没有影响,并主要通过吸附在催化剂的V活性位上使其脱硝性能有所减弱。当NaCl和Hg⁰同时存在时,吸附的Hg会与NaCl中引入的Cl结合,形成HgCl、HgCl₂,并部分取代-Na,最终形成-V-O…Hg及-V-O-Hg-Cl。
- 协同作用 /
- V₂O₅-WO₃/TiO₂催化剂 /
- NaCl /
- Hg⁰ /
- 失活
Abstract: The nano V₂O₅-WO₃/TiO₂ catalysts were prepared. NaCl was loaded on the catalysts by impregnation and Hg⁰ was loaded by adsorption. The samples were characterized by XRD, SEM, BET, NH₃-TPD and FT-IR measurements to investigate the effect of NaCl and Hg⁰ on the performance of V₂O₅-WO₃/TiO₂ SCR catalysts. Besides, the functional mechanism was proposed combining with previous conclusions. The results indicate that NaCl causes the agglomeration of catalysts, leading to the decrease of BET surface area. For NaCl poisoning catalysts, the deactivation is observed obviously with the increase of NaCl loadings. Brønsted acid sites (-V-OH) are neutralized by Na to ultimately form -V-O-Na and Cl-V-O-Na, resulting in the decline of catalytic activity. Hg⁰ shows no influence on the microstructure and phase composition of the catalysts. However, it can be adsorbed on the V active sites to weaken the De-NO_x activities slightly. When NaCl and Hg⁰ exist simultaneously, Hg⁰ will combine with Cl that is introduced from NaCl to form HgCl or HgCl₂ and partly replace Na, and -V-O…Hg or-V-O-Hg-Cl is produced finally.
- synergy /
- V₂O₅-WO₃/TiO₂ catalyst /
- NaCl /
- Hg⁰ /
- deactivation

HTML全文

参考文献(23)

ZHENG Y J, JENSEN A D, JOHNSSON J E. Laboratory investigation of selective catalytic reduction catalysts:Deactivation by potassium compounds and catalyst regeneration[J]. Ind Eng Chem Res, 2004, 43(4):941-947.

黄妍,童志权,伍斌,张俊丰. V₂O₅-CeO₂/TiO₂催化剂上低温氨选择性催化还原NO的性能[J].燃料化学学报, 2008, 36(5):616-620. (HUANG Yan, TONG Zhi-quan, WU Bin, ZHANG Jun-feng. Low temperature selective catalytic reduction of NO by ammonia over V₂O₅-CeO₂/TiO₂[J]. J Fuel Chem Technol, 2008, 36(5):616-620.)

胡石磊,叶代启,付名利. V₂O₅/TiO₂-SiO₂表面酸性对选择性催化还原NO及抗碱金属性能的影响[J].无机化学学报, 2008, 24(7):1113-1118. (HU Shi-lei, YE Dai-qi, FU Ming-li. Effect of surface acidity on NO reduction and resistance towards alkali poisoning over V₂O₅/TiO₂-SiO₂[J]. Chin J Inorg Chem, 2008, 24(7):1113-1118.)

CASAGRANDE L, LIETTI L, NOVA I, FORZATTI P, BAIKER A. SCR of NO by NH₃ over TiO₂-supported V₂O₅-MoO₃ catalysts:Reactivity and redox behavior[J]. Appl Catal B:Environ, 1999, 22(1):63-77.

LIETTI L, FORZATTI P, BREGANI F. Steady-state and transient reactivity study of TiO₂-supported V₂O₅-WO₃ De-NO_x catalysts:Relevance of the vanadium-tungsten interaction on the catalytic activity[J]. Ind Eng Chem Res, 1996, 35(11):3884-3892.

LARSSON A C, EINVALL J, ANDERSSON A, SANALL M. Targeting by comparison with laboratory experiments the SCR catalyst deactivation process by potassium and zinc salts in a large-scale biomass combustion boiler[J]. Energy Fuels, 2006, 20(4):1398-1405.

朱崇兵,金保升,仲兆平,李锋,陈玲霞,翟俊霞. K₂O对V₂O₃-WO₃/TiO₂催化剂的中毒作用[J].东南大学学报(自然科学版), 2008, 38(1):101-105. (ZHU Chong-bing, JIN Bao-sheng, ZHONG Zhao-ping, LI Feng, CHEN Ling-xia, ZHAI Jun-xia. Poisoning effect of K₂O on V₂O₅-WO₃/TiO₂ catalysts[J]. J Southeast Univ (Nat Sci), 2008, 38(1):101-105.)

KURT A C, MICHAEL S, HANS L. The formation of submicron aerosol particles, HCl and SO₂ in straw-fired boilers[J]. J Aerosol Sci, 1998, 29(4):421-444.

LISI L. Single and combined deactivating effect of alkali metals and HCl on commercial SCR catalysts[J]. Appl Catal B:Environ, 2004, 50(4):251-258.

LIETTI L, FORZATTI P, RAMIS G. Potassium doping of vanadia/titania de-NO_x catalysts:Surface characterization and reactivity study[J]. Appl Catal B:Environ, 1993, 3(1):13-35.

KAMATA H, TAKAHASHI K, ODENBRAND C U I. The role of K₂O in the selective reduction of NO with NH₃ over a V₂O₅(WO₃)/TiO₂ commercial selective catalytic reduction catalyst[J]. J Mol Catal A:Chem, 1999, 139(2/3):189-198.

胡石磊,叶代启.钾对催化剂选择性催化还原氮氧化物的性能影响特性研究[J].环境污染与防治, 2008, 30(7):43-46. (HU Shi-lei, YE Dai-qi. Effect of potassium on the selective reduction of NO by NH₃ on V₂O₅ catalysts[J]. Environ Pollut Control, 2008, 30(7):43-46.)

ZHANG X L, HUANG Z G, LIU Z Y. Effect of KCl on selective catalytic reduction of NO with NH₃ over a V₂O₅/AC catalyst[J]. Catal Commun, 2008, 9(5):842-846.

KAMATA H, UENO S, NAITO T. Mercury oxidation over the V₂O₅(WO₃)/TiO₂ commercial SCR catalyst[J]. Ind Eng Chem Res, 2008, 47(21):8136-8141.

GAO W, LIU Q C, WU C Y, LI H L, LI Y, YANG J, WU G F. Kinetics of mercury oxidation in the presence of hydrochloric acid and oxygen over a commercial SCR catalyst[J]. Chem Eng J, 2013, 220:53-60.

STOLLE R, KOESER H, GUTBERLET H. Oxidation and reduction of mercury by SCR DeNO_x catalysts under flue gas conditions in coal fired power plants[J]. Appl Catal B:Environ, 2014, 144:486-497.

TOPSØE N Y, TOPSØE H, DUMESIC J A. Vanadia/titania catalysts for selective catalytic reduction (SCR) of nitric oxide by ammonia. I. Combined temperature programmed in situ FT-IR and on-line mass spectroscopy studies[J]. J Catal, 1995, 151:226-240.

TOPSØE N Y, DUMESIC J A, TOPSØE H. Vanadia/titania catalysts for selective catalytic reduction (SCR) of nitric oxide by ammonia. Ⅱ. Studies of active sites and formulation of catalytic cycles[J]. J Catal, 1995, 151:241-252.

HE S, ZHOU J S, ZHU Y Q, LUO Z Y, NI M J, CEN K F. Mercury oxidation over a vanadia-based selective catalytic reduction catalyst[J]. Energy Fuels, 2009, 23:253-259.

SANDRA S, THOMAS H, HEINZ K. Adsorption and oxidation of mercury in tail-end SCR De-NO_x plants-Bench scale investigations and speciation experiments[J]. Appl Catal B:Environ, 2008, 79:286-295.

NIKSA S, FUJIWARA N. A predictive mechanism for mercury oxidation of selective catalytic reduction catalysts under coal-derived flue gas[J]. J Air Waste Manage, 2005, 55:1866-1875.

YUJIN E, SEOK H J, THANH A N, JINSOO K, TAI G L. Heterogeneous mercury reaction on a selective catalytic reduction (SCR) catalyst[J]. Catal Lett, 2008, 121:219-225.

LIU J, HE M F, ZHENG C G, CHANG M. Density functional theory study of mercury adsorption on V₂O₅(001) surface with implications for oxidation[J]. Proc Combust Inst, 2011, 33:2771-2777.

施引文献

资源附件(0)

访问统计