Effect of moisture adsorption and air pre-oxidation on spontaneous combustion liability of upgraded lignite
-
摘要: 为探究提质褐煤露天储存仍易自燃的规律和机制,选用自燃倾向性测定装置测定交叉点温度(CPT)等参数求得FCC,判定105-900℃提质褐煤在空气中吸湿预氧化前后的自燃倾向性变化;采用红外光谱仪、氮吸附仪、微量热仪等测定了各样品的化学结构变化、孔结构及吸湿性差异。结果表明,随提质温度的升高,提质新鲜样的自燃倾向性降低,但吸湿预氧化使200-500℃提质煤的自燃倾向性比其新鲜样显著增加,甚至接近原煤。预氧化增加了表面氧元素含量和氧化活性基团数量;脂肪侧链、含氧官能团和(提质后产生的)新自由基等氧化活性基团的存在及比表面积的增大,共同强化了提质样品的预氧化和自燃。吸湿不仅产生润湿热进一步加深预氧化,而且吸湿程度越大的提质样品,其自燃倾向性增强越显著。Abstract: The effect of moisture adsorption and air pre-oxidation on the spontaneous combustion liability of lignite upgraded was investigated for the purposes of obtaining the characteristics and mechanism of the spontaneous combustion liability during storage outside. By a testing apparatus for spontaneous combustion liability, the crossing-point temperature (CPT) for calculating the aggregative indicator FCC was measured for the fresh samples upgraded at the temperature ranging from 105℃ to 900℃ and for the upgraded samples suffering moisture adsorption and pre-oxidization. The changes of chemical structure were analyzed by Fourier transform infrared spectroscopy and energy dispersive spectrometer, and the evolution of pore structure was identified by physical adsorption experiments, and the difference of wetting heat for moisture absorption was determined by the micro calorimeter. The results show that the spontaneous combustion liability of fresh upgraded lignite is reduced with increasing upgrading temperature. But the adsorbing moisture and pre-oxidation make the spontaneous combustion liability of samples upgraded at 200-500℃ increase obviously comparing with the corresponding fresh upgraded samples. Pre-oxidation can increase the elemental oxygen content and the amount of oxidation active groups on the surface of samples. The oxidation active groups of aliphatic side chains, oxygen-containing functional groups, new free radicals from upgrading process, and the increase of specific surface area after deep upgrading all intensify the pre-oxidation and spontaneous combustion of the upgraded samples. The heat of wetting from adsorbing moisture not only further deepens the pre-oxidation, but also enhances the spontaneous combustion liability remarkably for the upgraded samples adsorbing more moisture.
-
表 1 原煤的工业分析和元素分析
Table 1 Proximate and ultimate analyses of raw coal
Sample Proximate analysis w/% Ultimate analysis wdaf /% Mad Ad Vdaf FCdaf N C S H O* Lignite 24.24 13.23 46.81 53.19 1.22 71.20 0.40 6.54 20.64 *: by difference 表 2 提质样品的工业分析
Table 2 Proximate analysis of upgraded samples
Upgrading temperature t/℃ SB w/% SA w/% Md Ad Vdaf FCdaf Md 25* - - - - 6.80 105 5.49 12.86 46.88 53.12 5.53 200 1.15 13.01 46.10 53.90 3.09 300 1.07 13.69 43.69 56.31 2.66 400 0.48 15.87 32.07 67.93 2.74 500 0.76 17.18 21.67 78.33 2.51 600 0.44 18.74 12.77 87.23 1.11 700 0.32 19.50 6.81 93.19 0.72 800 0.37 20.21 4.62 95.38 0.51 900 0.26 20.77 3.44 96.56 0.31 * raw coal is regarded as the sample at 25 ℃ -
[1] ZHAO H, YU J L, LIU J S, TAHMASEBI A.Experimental study on the self-heating characteristics of indonesian lignite during low temperature oxidation[J].Fuel, 2015, 150:55-63. doi: 10.1016/j.fuel.2015.01.108 [2] 刘鹏, 周扬, 鲁锡兰, 王岚岚, 潘铁英, 张德祥.先锋褐煤在水热处理过程中的结构演绎[J].燃料化学学报, 2016, 44(2):129-137. http://rlhxxb.sxicc.ac.cn/CN/abstract/abstract18771.shtmlLIU Peng, ZHOU Yang, LU Xi-lan, WANG Lan-lan, PAN Tie-ying, ZHANG De-xiang.Structural evolution of Xianfeng lignite during hydrothermal treatment[J].J Fuel Chem Technol, 2016, 44(2):129-137. http://rlhxxb.sxicc.ac.cn/CN/abstract/abstract18771.shtml [3] 郭彩应.一种活性煤焦的钝化工艺和钝化系统:中国, 20091003089.6[P].2010-07-21.GUO Cai-ying.Passivation process and passivation system of active coke:CN, 20091003089.6[P].2010-07-21. [4] 赵旭, 谭永鹏, 詹仲福, 高妍.一种褐煤干燥成型煤或半焦钝化精制的新工艺:中国, 201310129039.9[P].2014-10-15.ZHAO Xu, TAN Yong-peng, ZHAN Zhong-fu, GAO Yan.New technology for passivation refining of dried formed coal or semi coke of lignite:CN, 201310129039.9[P].2014-10-15. [5] NIMAJE D S, TRIPATHY D P.Characterization of some Indian coals to assess their liability to spontaneous combustion[J].Fuel, 2016, 163:139-147. doi: 10.1016/j.fuel.2015.09.041 [6] FEI Y, AZIZ A A, NASIR S, JACKSON W R, MARSHALL M, HULSTON J, CHAFFEE A L.The spontaneous combustion behavior of some low rank coals and a range of dried products[J].Fuel, 2009, 88(9):1650-1655. doi: 10.1016/j.fuel.2009.03.017 [7] 邓军, 赵婧昱, 张嬿妮, 吴慷, 张丹丹, 赵萌烨.陕西侏罗纪煤二次氧化自燃特性试验研究[J].中国安全科学学报, 2014, 24(1):34-40. http://www.cnki.com.cn/Article/CJFDTOTAL-ZAQK201401007.htmDENG Jun, ZHAO Jing-yu, ZHANG Yan-ni, WU Kang, ZHANG Dan-dan, ZHAO Meng-ye.Experimental study on spontaneous combustion characteristics of secondary oxidation of Jurassic coal[J].Chin Saf Sci J, 2014, 24(1):34-40. http://www.cnki.com.cn/Article/CJFDTOTAL-ZAQK201401007.htm [8] 张辛亥, 李青蔚.预氧化煤自燃特性试验研究[J].煤炭科学技术, 2014, 42(11):37-40. http://www.cnki.com.cn/Article/CJFDTOTAL-MTKJ201411011.htmZHANG Xin-hai, LI Qing-wei.Experiment study on spontaneous combustion characteristics of pre-oxidized coal[J].Coal Sci Technol, 2014, 42(11):37-40. http://www.cnki.com.cn/Article/CJFDTOTAL-MTKJ201411011.htm [9] 胡争国, 仲晓星, 王德明, 戚绪尧, 顾俊杰, 胡朝仕.煤自燃倾向性鉴定方法不合理性分析[J].煤炭科学技术, 2008, 36(8):49-52. http://www.cnki.com.cn/Article/CJFDTOTAL-MTKJ200808016.htmHU Zheng-guo, ZHONG Xiao-xing, WANG De-ming, QI Xu-yao, GU Jun-jie, HU Chao-shi.Analysis on the irrationality of evaluation method for coal spontaneous combustion tendentiousness[J].Coal Sci Technol, 2008, 36(8):49-52. http://www.cnki.com.cn/Article/CJFDTOTAL-MTKJ200808016.htm [10] 王海晖.煤自燃倾向性测试方法综述[J].安全与环境学报, 2009, 9(2):132-137. http://www.cnki.com.cn/Article/CJFDTOTAL-AQHJ200902032.htmWANG Hai-hui.Test methods for assessing susceptibility of coals to spontaneous combustion:A literature review[J].J Saf Environ, 2009, 9(2):132-137. http://www.cnki.com.cn/Article/CJFDTOTAL-AQHJ200902032.htm [11] OGUNSOLA O I, MIKULA R J.A study of spontaneous combustion characteristics of Nigerian coals[J].Fuel, 1991, 70(2):258-261. doi: 10.1016/0016-2361(91)90162-4 [12] 王寅, 王海晖.基于交叉点温度法煤自燃倾向性评定指标的物理内涵[J].煤炭学报, 2015, 40(2):377-382. http://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201502022.htmWANG Yin, WANG Hai-hui.Physical nature of the indexes for ranking self-heating tendency of coal based on the conventional crossing point temperature technique[J].J Chin Coal Soc, 2015, 40(2):377-382. http://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201502022.htm [13] 赵毅.傅里叶变换显微红外光谱对多孔菌类植物吸湿性的研究[D].北京:北京理工大学, 2015.ZHAO Yi.In-situ Micro-FTIR spectroscopic observation on the hydration process of polyporaceae fungi[D].Beijing:Beijing Institute of Technology, 2015. [14] KORKMAZ F, KOSTER S, YILDIZÖ, MANTELE W.In situ opening/closing of OmpG from E.coli and the splitting of β-sheet signals in ATR-FTIR spectroscopy[J].Spectrochim Acta, Part A, 2012, 91:395-401. doi: 10.1016/j.saa.2012.01.025 [15] 张锦萍, 李冬, 张成, 邱永琪, 殷立宝, 徐齐胜, 陈刚.低温热提质褐煤的理化结构演化及燃烧特性[J].煤炭学报, 2015, 40(3):671-677. http://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201503031.htmZHANG Jin-ping, LI Dong, ZHANG Cheng, QIU Yong-qi, YIN Li-bao, XU Qi-sheng, CHEN Gang.Physical/chemical structure evolution and combustion characteristics of mild thermally upgraded lignite[J].J Chin Coal Soc, 2015, 40(3):671-677. http://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201503031.htm [16] 吴爱坪, 潘铁英, 史新梅, 周丽芳, 刘瑞民, 张德祥, 高晋生.中低阶煤热解过程中自由基的研究[J].煤炭转化, 2012, 35(2):1-5. http://www.cnki.com.cn/Article/CJFDTOTAL-MTZH201202002.htmWU Ai-ping, PAN Tie-ying, SHI Xin-mei, ZHOU Li-fang, LIU Rui-min, ZHANG De-xiang, GAO Jin-sheng.Study on free radicals in low rank coal pyrolysis process[J].Coal Convers, 2012, 35(2):1-5. http://www.cnki.com.cn/Article/CJFDTOTAL-MTZH201202002.htm [17] 余振杰.中低阶煤热解及热解煤焦油的研究[D].上海:华东理工大学, 2013.YU Zhen-jie.Study on low-rank coal pyrolysis and characterization of coal tar[D].Shanghai:East China University of Science and Technology, 2013. [18] 王德明.煤氧化动力学理论及应用[M].北京:科学出版社, 2012, 13-25, 184-185, 216-223.WANG De-ming.The Coal Oxidation Dynamics:Theory and Application[M].Beijing:Science Press, 2012, 13-25, 184-185, 216-223. [19] 谢克昌.煤的结构与反应性[M].北京:科学出版社, 2002, 226-239.XIE Ke-chang.Coal Structure and Its Reactivity[M].Beijing:Science Press, 2002, 226-239. [20] 刘仲田.煤对氧分子的吸附机理研究[D].阜新:辽宁工程技术大学, 2007.LIU Zhong-Tian.Coal adsorption to oxygen molecules mechanism research[D].Fuxin:Liaoning Technical University, 2007. [21] 张双全, 姜尧发, 秦志宏, 孟宪梁, 程相林.成煤过程多样性与煤质变化规律[M].徐州:中国矿业大学出版社, 2013, 196-201.ZHANG Shuang-quan, JIANG YAO-fa, QIN Zhi-hong, CHENG Xiang-lin.Diversity of Coal-Forming Process and Variation of Coal Quality[M].Xuzhou:China University of Mining and Technology Press, 2013, 196-201. [22] ZHANG J W, CHOI W, ITO T, TAKAHASHI K, FUJITA M.Modelling and parametric investigations on spontaneous heating in coal pile[J].Fuel, 2016, 176:181-189. doi: 10.1016/j.fuel.2016.02.059 [23] 曲洋, 初茉, 丁力, 张慧慧, 王芳.热提质过程中褐煤的碎裂特性[J].中国矿业大学学报, 2014, 43(3):508-513. http://www.cnki.com.cn/Article/CJFDTOTAL-ZGKD201403023.htmQU Yang, CHU Mo, DING Li, ZHANG Hui-hui, WANG Fang.Fragmentation characteristic of lignite during heat upgrading[J].J China Univ Min Technol, 2014, 43(3):508-513. http://www.cnki.com.cn/Article/CJFDTOTAL-ZGKD201403023.htm [24] CHNRISTIE G B Y, MAINWARING D E.Oxidative and immersional heating on low rank coal surfaces[J].Fuel, 1992, 71(4):443-447. doi: 10.1016/0016-2361(92)90035-M