高硫煤镜质组热解过程中结构变化及有机硫形态变迁规律研究

李梅; 杨俊和; 张启锋; 夏红波; 常海洲; 孙慧

高硫煤镜质组热解过程中结构变化及有机硫形态变迁规律研究

李梅^1,2,
杨俊和^1,,
张启锋³,
夏红波³,
常海洲⁴,
孙慧⁴

1.
上海理工大学材料科学与工程学院, 上海 200093;
2.
北方民族大学化学与化学工程学院, 宁夏银川 750021;
3.
宝山钢铁股份有限公司, 上海 201900;
4.
上海理工大学理学院, 上海 200093

基金项目: 国家自然科学基金（21276156）。

详细信息

通讯作者:
杨俊和（1959- ），男，安徽巢湖人，教授，Tel：021-55270632，E-mail：jhyang@usst.edu.cn

中图分类号: TQ530
计量
- 文章访问数: 916
- HTML全文浏览量: 26
- PDF下载量: 557
- 被引次数: 0
出版历程
- 收稿日期: 2013-06-21
- 修回日期: 2013-09-06
- 刊出日期: 2014-02-28

Structure change and organic sulfur forms transformation during pyrolysis of high-sulfur vitrinite

1.
School of Materials Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China;
2.
School of Chemistry and Chemical Engineering, Beifang University of Nationalities, Yinchuan 750021, China;
3.
Baoshan Iron & Steel Co., Ltd, Shanghai 201900, China;
4.
School of Science, University of Shanghai for Science and Technology, Shanghai 200093, China

摘要

摘要: 用手选富集与离心分离相结合的方法，从两种全硫含量相近的新西兰煤（NXL；S_t，ad=1.84%）和山西煤（SX；S_t，ad=1.80%）中分离出高纯度镜质组。在高纯Ar气氛下，分别制备了300、500、700和1 000 ℃下的镜质组焦。用FT-IR研究了两种镜质组中的脂肪氢、芳香氢随温度的变化，结果表明，SX镜质组中脂肪氢的相对含量较高，在热解过程中活性高于同温度下的NXL镜质组；两种镜质组中的脂肪氢相对含量都随温度升高而降低，温度高于500 ℃时，SX镜质组中脂肪氢相对含量基本不变，当温度高于700 ℃时，NXL镜质组中的脂肪氢相对含量基本保持不变；热解过程芳香氢都表现出先增大后减小的趋势。用XPS研究了镜质组中的有机硫含量及形态随温度的变化，结果表明，SX镜质组中易分解的有机硫化物较多，在300 ℃以下即可分解完全；NXL镜质组中的有机硫化物分解完全在700 ℃左右，两种镜质组中的噻吩类硫的含量都随热解温度的升高而增加，砜类硫的含量随热解温度的升高而降低。
- 镜质组 /
- 有机硫变迁 /
- 热解 /
- FT-IR /
- XPS
Abstract: High purity vitrinite was separated and concentrated from New Zealand(NXL; S_t,ad=1.84%) and Shanxi(SX; S_t,ad=1.80%) coal which have similar sulfur content. The vitrinite was pyrolyzed in a tube furnace reactor under argon at 300, 500, 700 and 1 000 ℃. The effect of temperature on the functional group content and organic sulfur forms transformation was examined by Fourier transform infrared spectrum and X-ray photoelectron spectrum, respectively. The FT-IR experiments show that aliphatic hydrogen content in SX vitrinite and its reactivity is higher than those of NXL vitrinite at same temperature. The aliphatic hydrogen in both vitrinites decreases with increasing temperature. The aliphatic hydrogen content in SX and NXL vitrinite is unchanged when the temperature is above 500 and 700 ℃, respectively. The aromatic hydrogen increases first and then decreases with increasing temperature. The XPS results show that the organic sulphide, which is more thermal unstable, is richer on surface of SX vitrinite than that of NXL. It is decomposed completely below 300 and 700 ℃ for SX and NXL, respectively. The content of thiophenic compounds increases with increasing temperature, but that of sulfones compounds is just the reverse.
- vitrinite /
- organic sulfur transformation /
- pyrolysis /
- FT-IR /
- XPS

HTML全文

参考文献(21)

周师庸, 赵俊国. 炼焦煤性质与高炉焦炭质量[M]. 北京: 冶金工业出版社, 2008: 36-37. (ZHOU Shi-yong, ZHAO Jun-guo. Properties of coking coal and quality of coke for the blast furnace[M]. Beijing: Metallurgical Industry Press, 2008: 36-37.)

孙成功, 李保庆. 煤中有机硫形态结构和热解过程硫变迁特性的研究[J]. 燃料化学学报, 1997, 25(4): 358-362. (SUN Cheng-gong, LI Bao-qing. Characterization of organic sulfur forms in some Chinese coals by high pressure TPR and sulfur transfer during hydropyrolysis[J]. Journal of Fuel Chemistry and Technology, 1997, 25(4): 358-362.)

陈鹏. 用XPS研究兖州煤各显微组分中有机硫存在形态[J]. 燃料化学学报, 1997, 25(3): 238-241. (CHEN Peng. Application of XPS in study forms of organic sulfur in macerals of Yanzhou coal[J]. Journal of Fuel Chemistry and Technology, 1997, 25(3): 238-241.)

张代林, 李伟锋, 曾涛, 郑明东, 王培珍. 炼焦煤的热解过程研究[J]. 煤炭学报, 2012, 37(2): 323-327. (ZHANG Dai-lin, LI Wei-feng, ZENG Tao, ZHENG Ming-dong, WANG Pei-zhen. Study on pyrolyzing process of coking coals[J]. Journal of China Coal Society, 2012, 37(2): 323-327.)

KELEMEN S R, GORBATY M L, GEORGE G N, KWIATEK P J, SANSONE M. Thermal reactivity of sulphur forms in coal[J]. Fuel, 1991, 70(3): 396-402.

WALKER R, MASTALERZ M. Functional group and individual maceral chemistry of high volatile bituminous coals from southern Indiana: Controls on coking[J]. Int J Coal Geol, 2004, 58(3): 181-191.

PIETRZAK R, GRZYBEK T, WACHOWSKA H. XPS study of pyrite-free coals subjected to different oxidizing agents[J]. Fuel, 2007, 86(16): 2616-2624.

KELEMEN S R, GEORGE G N, GORBATY M L. Direct determination and quantification of sulphur forms in heavy petroleum and coals: 1.The X-ray photoelectron spectroscopy (XPS) approach[J]. Fuel, 1990, 69(8): 939-944.

KOZLOWSKI M. XPS study of reductively and non-reductively modified coals[J]. Fuel, 2004, 83(3): 259-265.

CERNY J. Structural dependence of CH bond absorptivities and consequences for FT-IR analysis of coals[J]. Fuel, 1996, 75(11): 1301-1306.

IBARRA J V, BONET A J, MOLINER R. Release of volatile sulfur compounds during low temperature pyrolysis of coal[J]. Fuel, 1994, 73(6): 933-939.

MACHNIKOWSKA H, KRZTON A, MACHNIKOWSKI J. The characterization of coal macerals by diffuse reflectance infrared spectroscopy[J]. Fuel, 2002, 81(2): 245-252.

常海洲, 曾凡桂, 李文英, 李军, 贾建波, 谢克昌. 西北地区侏罗纪煤显微组分结构的Micro-FTIR研究[J]. 光谱学与光谱分析, 2008, 28(7): 1535-1538. (CHANG Hai-zhou, ZENG Fan-gui, LI Wen-ying, LI Jun, JIA Jian-bo, XIE Ke-chang. Micro-FTIR study on structure of macerals from Jurassic coals in northwestern China[J]. Spectroscopy and Spectral Analysis, 2008, 28(7): 1535-1538.)

WANG M J, HU Y F, WANG J C, CHANG L P, WANG H. Transformation of sulfur during pyrolysis of inertinite-rich coals and correlation with their characteristics[J]. J Anal Appl Pyrolysis, 2013, 104: 585-592.

BROWN J R, KASRAI M, BANCROFT G M, TAN K H, GHEN J M. Direct identification of organic sulphur species in Rasa coal from sulphur L-edge X-ray absorption near-edge spectra[J]. Fuel, 1992, 71(6): 649-653.

PIETRZAK R, WACHOWSKA H. The influence of oxidation with HNO₃ on the surface composition of high-sulphur coals: XPS study[J]. Fuel Process Technol, 2006, 87(11): 1021-1029.

MARINOV S P, TYULIEV G, STEFANOVA M, CARLEER R, YPERMAN J. Low rank coals sulphur functionality study by AP-TPR/TPO coupled with MS and potentiometric detection and by XPS[J]. Fuel Process Technol, 2004, 85(4): 267-277.

闫金定. 炭载含硫化合物热解行为的研究[D]. 太原: 中国科学院山西煤炭化学研究所, 2005. (YAN Jin-ding. Behavior of sulfur transformation during pyrolysis of sulfur model compounds on carbon support[D]. Taiyuan: Institute of Coal Chemistry, Chinese Academy of Sciences, 2005.)

刘艳华. 煤中氮/硫的赋存形态及其变迁规律研究[D]. 西安: 西安交通大学, 2002. (LIU Yan-hua. An investigation on the forms and the fates of coal nitrogen/sulfur functionalities[D]. Xi'an: Xi'an Jiaotong University, 2002.)

HU H Q, ZHOU Q, ZHU S W, MEYER B, KRZACK S, CHEN G H. Product distribution and sulfur behavior in coal pyrolysis[J]. Fuel Process Technol, 2004, 85(8/10): 849-861.

LIU F R, LI W, CHEN H K, LI B Q. Uneven distribution of sulfurs and their transformation during coal pyrolysis[J]. Fuel, 2007, 86(3): 360-366.

施引文献

资源附件(0)

访问统计